SsangYong Musso. Manual - part 122

1F-72  ENGINE CONTROLS

SSANGYONG  Y158

1. The scan tool is malfunctioning.
2. Refer to the scan tool’s manual for repair.
Is the repair complete?
1. Using the scan tool, clear the Diagnostic Trouble

Codes (DTCs).

2. Attempt to start the engine.
Does the engine start and continue to run?
1. Allow the engine to idle until normal operation

temperature is reached.

2. Check if any DTCs are set.
Are any DTCs displayed that have not been diagnosed?

Step

Action

Value(s)

Yes

No

Data Link Connector Diagnosis (Cont'd)

-

 Go to Step 18

 Go to Step 2

-

Go to

applicable

DTC table

System OK

16

17

18

-

 Go to Step 17

-

ENGINE CONTROLS  1F-73

SSANGYONG  Y158

BLANK

1F-74  ENGINE CONTROLS

SSANGYONG  Y158

TROUBLE CODE DIAGNOSIS

CLEARING TROUBLE CODES

Notice: To prevent Engine Control Module (ECM) dam-
age, the key must be OFF when disconnecting or recon-
necting the power to the ECM (for example battery cable,
ECM pigtail connector, ECM fuse, jumper cables, etc.)

When the ECM sets a diagnostic trouble code (DTC),
the Malfunction Indicator Lamp (MIL) will be turned ON
and a DTC will be stored in the ECM’s memory. If the
problem is intermittent, the light will go out after 10 sec-

onds if  the fault is no longer present. The DTC will stay
in the ECM’s memory until the battery voltage for 10
seconds will clear all stored DTCs.

DTCs should be cleared after repairs have been com-
pleted. Some diagnostic tables will tell you to clear the
codes before using the chart. This allows the ECM to
set the DTC while going through the chart, which will
help to find the cause of the problem more quickly.

DIAGNOSTIC TROUBLE CODES

DTC

P0010

P0101

P0102

P0103

P0105

P0107

P0108

P0111

P0112

P0113

P0116

P0117

P0118

P0120

P0121

P0125

P0131

P0132

P0133

P0134-82

P0134-83

P0135-86

P0135-87

P0137

P0138

P0140

P0141-94

P0141-95

P0151

P0152

2.3L

DOHC

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

3.2L

DOHC

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

Type

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

Illuminate

MIL

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Description

Camshaft actuator short circuit to ground/battery/open

Mass air flow plausibility

Mass air flow low voltage

Mass air flow high voltage

Manifold absolute pressure plausibility

Manifold absolute pressure low voltage

Manifold absolute pressure high voltage

Intake air temperature plausibility

Intake air temperature low voltage

Intake air temperature high voltage

Engine coolant temperature plausibility

Engine coolant temperature low voltage

Engine coolant temperature high voltage

Throttle position sensor error

Throttle adaptation or throttle spring check

Engine coolant temperature warm-up

O2 bank 1 sensor 1 low voltage

O2 bank 1 sensor 1 high voltage

O2 bank 1 sensor 1 slow response

O2 bank 1 sensor 1 no activity detected

O2 bank 1 sensor 1 not lean after coasting shut down

O2 bank 1 sensor 1 heater short circuit to battery

O2 bank 1 sensor 1 heater short circuit to ground or open

O2 bank 1 sensor 2 low voltage

O2 bank 1 sensor 2 high voltage

O2 bank 1 sensor 2 not lean after coasting shut down

O2 bank 1 sensor 2 heater short circuit to battery

O2 bank 1 sensor 2 heater short circuit to ground or open

O2 bank 2 sensor 3 low voltage

O2 bank 2 sensor 3 high voltage

ENGINE CONTROLS  1F-75

SSANGYONG  Y158

Diagnostic Trouble Codes (Cont'd)

DTC

P0153

P0154-202

P0154-203

P0155-206

P0155-207

P0157

P0158

P0160

P0161-214

P0161-215

P0171

P0172

P0174

P0175

P0220

P0231

P0232

P0261

P0262

P0264

P0265

P0267

P0268

P0270

P0271

P0273

P0274

P0276

P0277

P0300

P0301

P0302

P0303

P0304

P0305

P0306

P0325

P0330

P0335

P0336

P0341

2.3L

DOHC

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

3.2L

DOHC

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

Type

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

B

Illuminate

MIL

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Yes

Description

O2 bank 2 sensor 3 slow response

O2 bank 2 sensor 3 no activity detected

O2 bank 2 sensor 3 not lean after coasting shut down

O2 bank 2 sensor 3 heater short circuit to battery

O2 bank 2 sensor 3 heater short circuit to ground or open

O2 bank 2 sensor 4 low voltage

O2 bank 2 sensor 4 high voltage

O2 bank 2 sensor 4 not lean after coasting shut down

O2 bank 2 sensor 4 heater short circuit to battery

O2 bank 2 sensor 4 heater short circuit to ground or open

Bank 1 system too lean

Bank 1 system too rich

Bank 2 system too lean

Bank 2 system too rich

Accelerator pedal position sensor malfunction

Fuel pump short circuit to ground or open

Fuel pump short circuit to battery

Injector 1: short circuit to ground or open

Injector 1: short circuit to battery

Injector 2: short circuit to ground or open

Injector 2: short circuit to battery

Injector 3: short circuit to ground or open

Injector 3: short circuit to battery

Injector 4: short circuit to ground or open

Injector 4: short circuit to battery

Injector 5: short circuit to ground or open

Injector 5: short circuit to battery

Injector 6: short circuit to ground or open

Injector 6: short circuit to battery

Multiple cylinder misfire

Cylinder 1 misfire

Cylinder 2 misfire

Cylinder 3 misfire

Cylinder 4 misfire

Cylinder 5 misfire

Cylinder 6 misfire

Knock sensor 1: noise level check

Knock sensor 2: noise level check

Crankshaft position sensor malfunction

Crankshaft position sensor signal range

Camshaft position sensor signal: cylinder 1 missing