BMW 3 (E46). Manual - part 57

 

  Index      BMW     BMW 3 (E46) - service repair manual 2006 year

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  55  56  57  58   ..

 

 

BMW 3 (E46). Manual - part 57

 

 

117-3

 

 

Camshaft Timing
Chains, Removing

Camshaft timing chain removal
requires that the engine oil pan be
removed. This requires raising the
engine and/or lowering the front
suspension subframe. See 

119

Lubrication System

. Also required is

removal of the VANOS unit and
disassembly of the intake and exhaust
camshaft sprocket assemblies as
described later in this repair group.

Special BMW service tools are needed
for timing chain removal and
installation procedures. The special
tools assure proper timing of the
valvetrain. Precise marks to set the
timing on the camshafts are not
provided for reassembly. Read the
procedures through before beginning
the job.nothing

CAUTION!

If the camshafts are not properly
timed, the pistons can contact the
valves.

 -

Disconnect negative (-) cable from
battery.

CAUTION!

Disconnecting the battery may
erase fault code(s) stored in
control module memory. Check
for fault codes using special
BMW diagnostic equipment.

Prior to disconnecting the
battery, read the battery
disconnection cautions given at
the front of this manual on page

viii.

Remove microfilter for interior
ventilation.

Remove microfilter housing:

Open wiring harness loom (A),
remove harness and lay aside.

Unfasten screws (B) and take off
lower microfilter housing.

Remove complete air filter housing:

Release mass air flow sensor clips
(A).

Remove filter housing mounting
screws (B).

Disconnect air duct connections
(C) and lift complete air filter
housing out of engine
compartment, pulling it forward
away from mass air flow sensor.

Note:

Mass air flow sensor remains attached
to air duct in above step.

Remove engine covers:

Remove plastic trim covers
(arrows).

Remove cover hold down bolts.

Drain engine coolant and remove
coolant hoses.

Remove expansion tank cap on
radiator.

Place a 3-gallon pail beneath
engine to capture coolant.

Remove engine block drain plug
on exhaust side near cylinder 2
(arrow).

WARNING!

Allow engine to cool before
opening or draining cooling
system.

Use caution when draining and
disposing of engine coolant.
Coolant is poisonous and lethal
to humans and pets. Pets are
attracted to coolant because of
its sweet smell and taste.
Consult a veterinarian
immediately if ingested by an
animal.

 -

Drain radiator into 3-gallon pail by
removing plastic drain plug at
lower left corner of radiator.

 -

Remove radiator cooling fan
shroud and viscous clutch cooling
fan (cars with automatic
transmission) or electric cooling
fan (cars with manual
transmission). See 

 

170 Radiator

and Cooling System

CAUTION!

On cars with viscous clutch, 32 mm
cooling fan mounting nut has left
hand threads.

Release locking clips and pull hoses
from thermostat housing (arrows).
Unbolt and remove thermostat houses.

Remove drive belts:

Use long-handled wrench to turn
A/C belt tensioner hex (A)
clockwise (against spring tension).
Remove A/C belt.

Similarly, turn main engine drive
belt tensioner hex (B) clockwise
and remove belt.

 -

Remove coolant pump pulley.

 -

Remove alternator cooling duct at
radiator support.

 

 

 

 

 

 

 

Content   ..  55  56  57  58   ..