Content .. 16 17 18

Volvo V40 (2019 year). Manual in english - page 18

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

Brake fluid - grade and volume

Brake fluid is the term for the medium in a

hydraulic brake system that is used to transfer

pressure from the master brake cylinder to the

mechanical brakes.

Prescribed grade: Volvo Original Dot 4 class 6

or equivalent.

Volume: 0.6 litres

Related information

• Brake and clutch fluid - level (p. 350)

398

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

Fuel tank - volume

Fuel tank volume for each respective engine

alternative can be read in the table.

V40

Volume (litres)

Prescribed grade

Engine

Petrol

approx. 62

Fuel - petrol (p. 297)

Diesel

approx. 62

Fuel - diesel (p. 298)

Related information

• Filling up with fuel (p. 296)

• Engine specifications (p. 391)

399

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

Tank volume for AdBlue^®2

Air conditioning, fluid - volume and

Decal for R1234yf

Approx. 16.5 litres of the AdBlue additive can be

grade

added to the tank.

The climate control system in the car uses a

refrigerant, either R1234yf or R134a, depend-

ing on market. Information about which refriger-

Related information

ant the car's climate control system uses can be

• AdBlue^® - checking and topping up (p. 303)

seen on a decal, located on the inside of the

bonnet.

Prescribed grades and volumes of fluids and

lubricants in the air conditioning system can be

The label is fitted on the inside of the bonnet.

read in the tables below.

A/C decal

Decal for R134a

The label is fitted on the inside of the bonnet.

2 Registered trademark belonging to Verband der Automobilindustrie e.V. (VDA)

400

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

Symbol explanation R1234yf

Evaporator

WARNING

Symbol

Meaning

The air conditioning system contains pressur-

ised refrigerant R134a. This system must only

IMPORTANT

Caution

be serviced and repaired by an authorised

The A/C system's evaporator must never be

workshop.

repaired or replaced with a previously used

evaporator. A new evaporator must be certi-

Cars with refrigerant R1234yf

fied and labelled in accordance with SAE

Mobile air conditioning system

J2842.

(MAC)

Weight

Prescribed grade

575 g

R1234yf

Related information

Lubricant type

• Climate control system - fault tracing and

WARNING

repair (p. 351)

The air conditioning system contains pressur-

ised refrigerant R1234yf. In accordance with

A trained and certified technician is

SAE J2845 (Technician Training for Safe

required in order to service the

Service and Containment of Refrigerants

mobile air conditioning system

Used in Mobile A/C System), service and

(MAC)

repair of the refrigerant system must only be

performed by trained and certified technicians

Flammable refrigerants

in order to ensure the safety of the system.

Compressor oil

Volume

Prescribed grade

Refrigerant

60 ml

PAG oil

Cars with refrigerant R134a

Weight

Prescribed grade

625 g

R134a

401

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

Fuel consumption and CO2

urban driving

manual gearbox

emissions

Fuel consumption in a vehicle is measured in

extra-urban driving

Automatic gearbox

litres per 100 km and CO₂ emissions in grams

CO₂ per km.

combined driving

NOTE

Explanation

Tyre rating for rolling resistance

If the consumption and emission data is miss-

gram CO₂/km

according to EU directive no.

ing then it is included in the enclosed supple-

1222/2009

ment.

litre/100 km

NOTE

Not all engines are available in all markets.

V40

183

7.9

110

4.7

137

5.9

186

8.0

112

4.8

139

6.0

T2 (B4204T17)

189

8.1

115

4.9

142

6.1

193

8.3

117

5.0

145

6.2

402

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

V40

162

7.0

110

4.7

129

5.6

165

7.1

112

4.8

131

5.6

T2 (B4154T3)

168

7.2

114

4.9

133

5.7

171

7.4

116

5.0

136

5.9

186

8.0

112

4.8

139

6.0

187

8.1

114

4.9

141

6.1

T3 (B4204T33)

189

8.1

116

5.0

143

6.1

190

8.2

118

5.1

145

6.2

162

7.0

115

4.9

132

5.7

164

7.0

117

5.0

134

5.8

T3 (B4154T2)

165

7.1

119

5.1

136

5.9

167

7.2

121

5.2

138

6.0

D2 (D4204T13)

}}

403

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

V40

D2 (D4204T13)

D3 (D4204T16)

Fuel consumption

heavily the car is loaded, increases fuel consump-

•

If the car is equipped with extra equipment

Fuel consumption and emission values in the

tion and carbon dioxide emissions.

that affects the car's weight.

table above are based on specific EU driving

There are several reasons for increased fuel con-

•

The driver's driving style.

cycles (see below), that apply to cars with kerb

sumption compared with the table's values.

•

If the customer chooses wheels other than

weight in the basic version and without extra

Examples of this are:

those fitted as standard on the model's basic

equipment. The car's weight may increase

version then rolling resistance may increase.

depending on equipment. This, as well as how

404

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

• High speed results in increased wind resis-

this reason the tests are carried out under close

•

Fuel - diesel (p. 298)

tance.

scrutiny and only with the car's basic functions

•

Weights (p. 388)

(e.g. air conditioning, radio, etc. switched off). As

• Fuel quality, road and traffic conditions,

a consequence of this the results from the official

weather and the condition of the car.

figures are not obviously representative of what

A combination of the above-mentioned examples

the customer sees during actual usage.

can result in significantly increased consumption.

The regulations cover the driving cycles for

Large deviations in fuel consumption may arise in

"Urban driving" and "Extra-urban driving":

a comparison with the EU driving cycles (see

below) which are used in the certification of the

• Urban driving - the measurement starts

car and on which the consumption figures in the

with cold starting the engine. The driving is

table are based. For further information, please

simulated.

refer to the regulations referred to.

• Extra-urban driving - the car is accelerated

and braked at speeds between 0-120 km/h

Consumption is higher and power output lower

(0-75 mph). The driving is simulated.

for fuel with an octane rating of 91 RON.

Cars with manual gearbox are started in 2nd

gear.

NOTE

Extreme weather conditions, driving with a

The official value for combined driving, which is

trailer or driving at high altitudes in combina-

reported in the table, is a combination of the

tion with fuel quality are factors that consider-

results from the "Urban driving" and "Extra-urban

ably increase the car's fuel consumption.

driving" driving cycles, in accordance with legal

requirements.

EU driving cycles

The exhaust gases are collected in order to

Official fuel consumption figures are based on

extrapolate the carbon dioxide emissions (CO₂

two standardised driving cycles in a laboratory

emissions) during the two driving cycles. These

environment ("EU driving cycles") all in accord-

are then analysed and give the value for CO₂

ance with EU Regulation no 692/2008,

emissions.

715/2007 (Euro 5 / Euro 6), 2017/1151 and

2017/1153. Since the driving cycles are also

Related information

used for quality control, there are significant

• Economical driving (p. 304)

requirements for repeatability of the tests. For

• Fuel - petrol (p. 297)

405

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

Wheels and tyres - approved

approved combinations of wheel rims and tyres.

For information on the minimum permitted load

dimensions

Information on engine and type of gearbox is

index (LI) and the minimum permitted speed rat-

required to read the table. For information with

ing (SS), see Load index and speed rating

In certain countries not all approved dimensions

respect to these details, see Type designations

(p. 408).

are indicated by the registration document or

(p. 384).

other documents. The following table shows all

✓ = Approved

V40

man/

205/55R16

205/50R17

225/45R17

Engine

aut

7x16x50

7x17x50

7,5x17x52,5

225/40R18

235/35R19^A

6,5x16x52,5

7x17x52.5

7x17x50

7,5x18x52,5

8x19x50

B4154T3

aut

✓

B4154T5

aut

✓

B4204T17

man

✓

B4154T2

aut

✓

B4154T4

aut

✓

B4204T33

man

✓

B4204T19

aut

✓

B4204T11

aut

✓

B4204T41

aut

✓

D4204T8

man/aut

✓

D4204T13

man/aut

✓

D4204T16

man/aut

✓

406

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

V40

man/

205/55R16

205/50R17

225/45R17

Engine

aut

7x16x50

7x17x50

7,5x17x52,5

225/40R18

235/35R19^A

6,5x16x52,5

7x17x52.5

7x17x50

7,5x18x52,5

8x19x50

D4204T9

aut

✓

D4204T14

aut

✓

A Only approved for cars equipped with 19" tyres from the factory.

Related information

• Tyres - dimensions (p. 321)

• Tyres - speed ratings (p. 322)

• Tyres - load index (p. 322)

• Wheel and wheel rim dimensions (p. 321)

407

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

Load index and speed rating

tion on engine and type of gearbox is required to

The table below shows the minimum permitted

read the table. For information with respect to

these details, see Type designations (p. 384).

load index (LI) and speed rating (SS). Informa-

V40

man/

Engine

aut

Minimum permitted load index (LI)^A

Minimum permitted speed rating (SS)^B

B4154T3

aut

B4154T5

aut

B4204T17

man

B4154T2

aut

B4154T4

aut

B4204T33

man

B4204T19

aut

B4204T11

aut

B4204T41

aut

D4204T8

man/aut

D4204T13

man/aut

D4204T16

man/aut

D4204T9

aut

D4204T14

aut

A The tyre's load index must be at least equal to or greater than indicated in the table.

B The tyre's speed rating must be at least equal to or greater than indicated in the table.

408

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

Related information

• Wheels and tyres - approved dimensions

(p. 406)

• Tyres - approved tyre pressures (p. 410)

• Tyres - load index (p. 322)

• Tyres - speed ratings (p. 322)

409

-------------------------------------------------------------------------------------------------------------------------------------------------------------

SPECIFICATIONS

Tyres - approved tyre pressures

Approved tyre pressures for each respective

engine alternative can be read in the table.

V40

Tyre size

Speed

Load, 1-3 persons

Max. load

ECO pressure^A

Engine

(km/h)

Front

Rear

Front

Rear

Front/rear

(kPa)^B

(kPa)

205/55 R16

0 - 160^C

230

260

205/50 R17

160+^D

250

300

280

All engines

225/45 R17

225/40 R18

0 - 160^C

230

260

235/35 R19

160+^D

270

320

300

Temporary Spare Tyre

max. 80^E

420

A Economical driving.

B In certain countries there is the "bar" unit beside the SI unit "Pascal": 1 bar = 100 kPa.

C 0 - 100 mph

D 100+ mph

E max 50 mph

NOTE

• Tyres - air pressure (p. 320)

• Type designations (p. 384)

All engines, tyres or combinations of these

are not always available in all markets.

Related information

• Wheels and tyres - approved dimensions

(p. 406)

• Tyres - dimensions (p. 321)

410

Content .. 16 17 18