Content      ..     15      16      17      18     ..

Suzuki Kizashi (2010 year). Manual - part 17

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

WARNING

WARNING

You should take extreme care when

(Continued)

working on your vehicle to prevent

•

Do not touch ignition wires or other

accidental injury. Here are a few pre-

ignition system parts when starting

cautions that you should be espe-

the engine or when the engine is

cially careful to observe:

running, or you could receive an

•

To prevent damage or unintended

electric shock.

inflation of the air bag system, be

•

Be careful not to touch a hot

sure the battery is disconnected

engine, exhaust manifold and

and the engine switch has been

pipes, muffler, radiator and water

pressed to change the ignition

hoses.

mode to “LOCK” (OFF) and this

•

Do not allow smoking, sparks or

mode is kept unchanged for at

flames around fuel or the battery.

60A187S

least 90 seconds before performing

Flammable fumes are present.

any electrical service work on your

•

Do not get under your vehicle if it is

SUZUKI. Do not touch air bag sys-

supported only with the portable

tem components or wires. The

jack provided in your vehicle.

wires are wrapped with yellow tape

•

Be careful not to cause accidental

or yellow tubing, and the couplers

short circuits between the positive

are yellow for easy identification.

and negative battery terminals.

•

Do not leave the engine running in

•

Keep used oil, engine coolant and

garages or other confined areas.

other fluids away from children and

•

When the engine is running, keep

pets. Dispose of used fluids prop-

hands, clothing, tools and other

erly; never pour them on the

objects away from the moving fan

ground, into sewers, etc.

and drive belt.

•

When it is necessary to do service

work with the engine running, make

sure that the parking brake is set

fully and the transaxle is in Neutral

(for manual transaxle vehicles) or

Park (for CVT).

(Continued)

7-1

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

NOTICE (for U.S.A.)

Maintenance Schedule

Maintenance, replacement or repair of

WARNING

The following table shows the times when

the emission control devices and sys-

you should perform regular maintenance

The shock absorbers are filled with

tems may be performed by any automo-

on your vehicle. This table shows in miles,

high pressure gas. Never attempt to

bile repair establishment or individual

kilometers and months when you should

disassemble them or throw them into

using any part which has been certified

perform inspections, adjustments, lubrica-

a fire. Avoid storing them near a

under the provisions in the Clean Air

tion and other services. These intervals

heater or heating device. When

Act sec. 207. (a) (2).

should be shortened if driving is usually

scrapping the absorber, the gas must

done under severe conditions

(refer to

be released from the absorber safely.

“Maintenance Recommended Under

Ask your dealer for assistance.

Severe Driving Conditions”).

WARNING

SUZUKI recommends that mainte-

nance on items marked with an aster-

isk

(*) be performed by your

authorized SUZUKI dealer or a quali-

fied service technician. If you are

qualified, you may perform mainte-

nance on the unmarked items by

referring to the instructions in this

section. If you are not sure whether

you can successfully complete any of

the unmarked maintenance jobs, ask

your authorized SUZUKI dealer to do

the maintenance for you.

CAUTION

Whenever it becomes necessary to

replace parts on your vehicle, it is

recommended that you use genuine

SUZUKI replacement parts or their

equivalent.

7-2

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

Periodic Maintenance Schedule except CANADA

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

Interval: This interval should be judged by

miles (x 1000)

7.5

15

22.5

30

37.5

45

52.5

60

67.5

75

odometer reading or months, whichever comes

km (x 1000)

12.5

25

37.5

50

62.5

75

87.5

100

112.5

125

first.

months

7.5

15

22.5

30

37.5

45

52.5

60

67.5

75

ENGINE & EMISSION CONTROL

1. Drive belt

Inspect for damage

-

-

-

I

-

-

-

I

-

-

*2. Valve lash (clearance)

-

-

-

-

-

-

-

I

-

-

3. Engine oil and oil filter

R

R

R

R

R

R

R

R

R

R

*4. Cooling system hoses and connections

-

-

-

I

-

-

-

I

-

-

5. Engine coolant

SUZUKI LLC: Standard (Green)

-

-

-

R

-

-

-

R

-

-

SUZUKI LLC: Super (Blue) (#1)

First time only: Replace at 150000 km (90000 miles) or 90 months

Second time and after: Replace every 75000 km (45000 miles) or 45 months

*6. Exhaust pipes and mountings

-

-

-

I

-

-

-

I

-

-

*7. EVAP canister

Replace every 250000 km (150000 miles) or 180 months

*8. Emission-related hoses & tubes

-

-

-

-

-

-

-

I

-

-

9. Spark plugs

-

-

-

-

-

-

-

R

-

-

*10. Ignition coil (plug cap)

-

-

-

I

-

-

-

I

-

-

*11. Fuel tank & cap

-

I

-

I

-

I

-

I

-

I

12. Air cleaner filter element (paved road)

-

-

-

R

-

-

-

R

-

-

*13. Fuel filter

-

-

-

-

-

-

-

-

-

-

*14. Fuel lines and connections

-

-

-

I

-

-

-

I

-

-

*15. Canister air suction filter

Replace every 250000 km (150000 miles) or 180 months

#1: Be sure to perform the engine coolant level check under the daily inspection in “OPERATING YOUR VEHICLE” section.

If you replace the engine coolant other than the SUZUKI LLC: Super (Blue), follow the schedule of SUZUKI LLC: Standard (Green).

7-3

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

Interval: This interval should be judged by

miles (x 1000)

82.5

90

97.5

105

112.5

120

127.5

135

142.5

150

odometer reading or months, whichever comes

km (x 1000)

137.5

150

162.5

175

187.5

200

212.5

225

237.5

250

first.

months

82.5

90

97.5

105

112.5

120

127.5

135

142.5

150

ENGINE & EMISSION CONTROL

1. Drive belt

Inspect for damage

-

I

-

-

-

I

-

-

-

I

*2. Valve lash (clearance)

-

-

-

-

-

I

-

-

-

-

3. Engine oil and oil filter

R

R

R

R

R

R

R

R

R

R

*4. Cooling system hoses and connections

-

I

-

-

-

I

-

-

-

I

5. Engine coolant

SUZUKI LLC: Standard (Green)

-

R

-

-

-

R

-

-

-

R

SUZUKI LLC: Super (Blue) (#1)

First time only: Replace at 150000 km (90000 miles) or 90 months

Second time and after: Replace every 75000 km (45000 miles) or 45 months

*6. Exhaust pipes and mountings

-

I

-

-

-

I

-

-

-

I

*7. EVAP canister

Replace every 250000 km (150000 miles) or 180 months

*8. Emission-related hoses & tubes

-

-

-

-

-

I

-

-

-

I

9. Spark plugs

-

-

-

-

-

R

-

-

-

-

*10. Ignition coil (plug cap)

-

I

-

-

-

I

-

-

-

I

*11. Fuel tank & cap

-

I

-

I

-

I

-

I

-

I (#2)

12. Air cleaner filter element (paved road)

-

R

-

-

-

R

-

-

-

R

*13. Fuel filter

-

-

-

-

-

-

-

-

-

R

*14. Fuel lines and connections

-

I

-

-

-

I

-

-

-

I (#2)

*15. Canister air suction filter

Replace every 250000 km (150000 miles) or 180 months

#1: Be sure to perform the engine coolant level check under the daily inspection in “OPERATING YOUR VEHICLE” section.

If you replace the engine coolant other than the SUZUKI LLC: Super (Blue), follow the schedule of SUZUKI LLC: Standard (Green).

#2: Inspect at 250000 km (150000 miles) or 180 months.

NOTE:

The maintenance services enclosed with rectangle are recommended maintenance items.

The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform recom-

mended maintenance items enclosed with a rectangle will not nullify the emission warranty or limit recall liability prior to the completion

of the vehicle’s useful life. SUZUKI, however, urges that all recommended maintenance services be performed at the indicated inter-

vals and the maintenance recorded.

7-4

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

miles (x 1000)

7.5

15

22.5

30

37.5

45

52.5

60

67.5

75

Interval: This interval should be judged by odometer

km (x 1000)

12.5

25

37.5

50

62.5

75

87.5

100

112.5

125

reading or months, whichever comes first.

months

7.5

15

22.5

30

37.5

45

52.5

60

67.5

75

CHASSIS AND BODY

1. Clutch (for manual transaxle)

Pedal and fluid level

-

I

-

I

-

I

-

I

-

I

*2. Brake discs and pads

(front, rear)

I

-

I

-

I

-

I

-

I

-

*3. Brake hoses and pipes

I

-

I

-

I

-

I

-

I

-

4. Brake fluid level check, *replacement

-

I

-

I

-

I

-

R

-

I

5. Brake pedal stroke check, *adjustment

-

I

-

I

-

I

-

I

-

I

6. Parking brake lever and *cable

Lever movement check, *adjustment

I

-

I

-

I

-

I

-

I

-

7. Tires (including tire rotation)

I

I

I

I

I

I

I

I

I

I

8. Wheel discs

I

I

I

I

I

I

I

I

I

I

*9. Suspension system

I

I

I

I

I

I

I

I

I

I

*10. Propeller shafts (i-AWD)/Drive axle boots

I

I

I

I

I

I

I

I

I

I

*11. Manual transaxle oil Level check & replacement

Genuine “SUZUKI GEAR OIL 75W-80”

I

-

-

I

-

I

-

I

-

I

Other than “SUZUKI GEAR OIL 75W-80”

I

-

-

R

-

I

-

R

-

I

12. Continuously variable transaxle (CVT)

Fluid level

-

I

-

I

-

I

-

I

-

I

*Fluid hose

-

-

-

-

-

I

-

-

-

-

*13. Transfer oil (i-AWD)

I

-

-

I

-

I

-

R

-

I

*14. Rear differential oil (i-AWD)

R

-

-

I

-

I

-

I

-

I

15. Steering system

Steering wheel movement,

*linkage

I

I

I

I

I

I

I

I

I

I

16. Power steering (if equipped)

I

I

I

I

I

I

I

I

I

I

17. All latches, hinges and locks

I

I

I

I

I

I

I

I

I

I

18. Air conditioner filter element (if equipped)

-

I

-

R

-

I

-

R

-

I

7-5

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

miles (x 1000)

82.5

90

97.5

105

112.5

120

127.5

135

142.5

150

Interval: This interval should be judged by odometer

km (x 1000)

137.5

150

162.5

175

187.5

200

212.5

225

237.5

250

reading or months, whichever comes first.

months

82.5

90

97.5

105

112.5

120

127.5

135

142.5

150

CHASSIS AND BODY

1. Clutch (for manual transaxle)

Pedal and fluid level

-

I

-

I

-

I

-

I

-

I

*2. Brake discs and pads

(front, rear)

I

-

I

-

I

-

I

-

I

-

*3. Brake hoses and pipes

I

-

I

-

I

-

I

-

I

-

4. Brake fluid level check, *replacement

-

I

-

I

-

R

-

I

-

I

5. Brake pedal stroke check, *adjustment

-

I

-

I

-

I

-

I

-

I

6. Parking brake lever and *cable

Lever movement check, *adjustment

I

-

I

-

I

-

I

-

I

-

7. Tires (including tire rotation)

I

I

I

I

I

I

I

I

I

I

8. Wheel discs

I

I

I

I

I

I

I

I

I

I

*9. Suspension system

I

I

I

I

I

I

I

I

I

I

*10. Propeller shafts (i-AWD)/Drive axle boots

I

I

I

I

I

I

I

I

I

I

*11. Manual transaxle oil Level check & replacement

Genuine “SUZUKI GEAR OIL 75W-80”

-

R

-

I

-

I

-

I

-

I

Other than “SUZUKI GEAR OIL 75W-80”

-

R

-

I

-

R

-

I

-

R

12. Continuously variable transaxle (CVT)

Fluid level

-

I

-

I

-

I

-

I

-

I

*Fluid hose

-

I

-

-

-

-

-

I

-

-

*13. Transfer oil (i-AWD)

-

I

-

I

-

R

-

I

-

I

*14. Rear differential oil (i-AWD)

-

I

-

I

-

I

-

I

-

I

15. Steering system

Steering wheel movement,

*linkage

I

I

I

I

I

I

I

I

I

I

16. Power steering (if equipped)

I

I

I

I

I

I

I

I

I

I

17. All latches, hinges and locks

I

I

I

I

I

I

I

I

I

I

18. Air conditioner filter element (if equipped)

-

R

-

I

-

R

-

I

-

R

NOTE:

This table shows the service schedule up to 250000 km (150000 miles).

Beyond 250000 km (150000 miles), perform the same services at the same intervals shown in the chart.

Beyond 250000 km (150000 miles), the maintenance services enclosed with a rectangle are required.

7-6

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

Maintenance Recommended under Severe Driving Conditions except CANADA

Follow this schedule if your car is mainly operated under one or more of the following conditions:

• When most trips are less than 6 kilometers (4 miles)

• When most trips are less than 16 kilometers (10 miles) and outside temperature remain below freezing.

• Idling and/or low-speed operation in stop-and-go traffic.

• Operating in dusty areas.

Schedule should also be followed if the car is used for delivery service, police, taxi or other commercial applications.

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

Interval: This interval should be judged by

miles (x 1000)

3

6

9

12

15

18

21

24

27

30

33

36

39

odometer reading or months, whichever

km (x 1000)

5

10

15

20

25

30

35

40

45

50

55

60

65

comes first.

months

3

6

9

12

15

18

21

24

27

30

33

36

39

ENGINE & EMISSION CONTROL

1. Drive belt

Inspect for damage

-

-

-

-

-

-

-

-

-

I

-

-

-

*2. Valve lash (clearance)

-

-

-

-

-

-

-

-

-

-

-

-

-

3. Engine oil and oil filter

R

R

R

R

R

R

R

R

R

R

R

R

R

*4. Cooling system hoses and connections

-

-

-

-

I

-

-

-

-

I

-

-

-

5. Engine coolant

SUZUKI LLC: Standard (Green)

-

-

-

-

-

-

-

-

-

R

-

-

-

SUZUKI LLC: Super (Blue) (#1)

First time only: Replace at 150000 km (90000 miles) or 90 months

Second time and after: Replace every 75000 km (45000 miles) or 45 months

*6. Exhaust pipes and mountings

-

-

-

-

I

-

-

-

-

I

-

-

-

*7. EVAP canister

Replace every 250000 km (150000 miles) or 180 months

*8. Emission-related hoses & tubes

-

-

-

-

-

-

-

-

-

-

-

-

-

9. Spark plugs

-

-

-

-

-

-

-

-

-

-

-

-

-

*10. Ignition coil (plug cap)

-

-

-

-

-

-

-

-

-

I

-

-

-

*11. Fuel tank & cap

-

-

-

-

I

-

-

-

-

I

-

-

-

12. Air cleaner filter element (paved road)

I

I

I

I

I

I

I

I

I

R

I

I

I

*13. Fuel filter

Replace every 250000 km (150000 miles) or 150 months

*14. Fuel lines and connections

-

-

-

-

I

-

-

-

-

I

-

-

-

*15. Canister air suction filter

-

-

-

-

-

-

-

-

-

-

-

-

-

#1: Be sure to perform the engine coolant level check under the daily inspection in “OPERATING YOUR VEHICLE” section.

If you replace the engine coolant other than the SUZUKI LLC: Super (Blue), follow the schedule of SUZUKI LLC: Standard (Green).

7-7

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

Interval: This interval should be judged by

miles (x 1000)

42

45

48

51

54

57

60

63

66

69

72

75

odometer reading or months, whichever

km (x 1000)

70

75

80

85

90

95

100

105

110

115

120

125

comes first.

months

42

45

48

51

54

57

60

63

66

69

72

75

ENGINE & EMISSION CONTROL

1. Drive belt

Inspect for damage

-

-

-

-

-

-

I

-

-

-

-

-

*2. Valve lash (clearance)

-

-

-

-

-

-

I

-

-

-

-

-

3. Engine oil and oil filter

R

R

R

R

R

R

R

R

R

R

R

R

*4. Cooling system hoses and connections

-

I

-

-

-

-

I

-

-

-

-

I

5. Engine coolant

SUZUKI LLC: Standard (Green)

-

-

-

-

-

-

R

-

-

-

-

-

SUZUKI LLC: Super (Blue) (#1)

First time only: Replace at 150000 km (90000 miles) or 90 months

Second time and after: Replace every 75000 km (45000 miles) or 45 months

*6. Exhaust pipes and mountings

-

I

-

-

-

-

I

-

-

-

-

I

*7. EVAP canister

Replace every 250000 km (150000 miles) or 180 months

*8. Emission-related hoses & tubes

-

-

-

-

-

-

I

-

-

-

-

-

9. Spark plugs

-

-

-

-

-

-

R

-

-

-

-

-

*10. Ignition coil (plug cap)

-

-

-

-

-

-

I

-

-

-

-

-

*11. Fuel tank & cap

-

I

-

-

-

-

I

-

-

-

-

I

12. Air cleaner filter element (paved road)

I

I

I

I

I

I

R

I

I

I

I

I

*13. Fuel filter

Replace every 250000 km (150000 miles) or 150 months

*14. Fuel lines and connections

-

I

-

-

-

-

I

-

-

-

-

I

*15. Canister air suction filter

-

-

-

-

-

-

-

-

-

-

-

R

#1: Be sure to perform the engine coolant level check under the daily inspection in “OPERATING YOUR VEHICLE” section.

If you replace the engine coolant other than the SUZUKI LLC: Super (Blue), follow the schedule of SUZUKI LLC: Standard (Green).

7-8

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

miles (x 1000)

3

6

9

12

15

18

21

24

27

30

33

36

39

Interval: This interval should be judged by odometer

km (x 1000)

5

10

15

20

25

30

35

40

45

50

55

60

65

reading or months, whichever comes first.

months

3

6

9

12

15

18

21

24

27

30

33

36

39

CHASSIS AND BODY

1. Clutch (for manual transaxle)

Pedal and fluid level

-

-

-

-

I

-

-

-

-

I

-

-

-

*2. Brake discs and pads

(front, rear)

-

I

-

I

-

-

-

I

-

-

-

I

-

*3. Brake hoses and pipes

-

I

-

I

-

-

-

I

-

-

-

I

-

4. Brake fluid level check, *replacement

-

-

-

-

I

-

-

-

-

I

-

-

-

5. Brake pedal stroke check, *adjustment

-

-

-

-

I

-

-

-

-

I

-

-

-

6. Parking brake lever and *cable

Lever movement check, *adjustment

-

I

-

-

I

-

-

-

-

I

-

-

-

7. Tires (including tire rotation)

-

I

-

I

-

I

-

I

-

I

-

I

-

8. Wheel discs

-

I

-

I

-

I

-

I

-

I

-

I

-

*9. Wheel bearings

-

-

-

I

-

-

-

I

-

-

-

I

-

*10. Suspension system

-

I

-

I

-

I

-

I

-

I

-

I

-

*11. Propeller shafts (i-AWD)/Drive axle boots

-

I

-

I

-

I

-

I

-

I

-

I

-

*12. Manual transaxle oil Level check & replacement

Genuine “SUZUKI GEAR OIL 75W-80”

-

-

-

-

I

-

-

-

-

I

-

-

-

Other than “SUZUKI GEAR OIL 75W-80”

-

-

-

-

R

-

-

-

-

R

-

-

-

13. Continuously variable transaxle (CVT)

Fluid level

-

-

-

-

I

-

-

-

-

I

-

-

-

*Fluid deterioration check*

2

-

-

-

-

I

-

-

-

-

I

-

-

-

*Fluid hose

-

-

-

-

-

-

-

-

-

-

-

-

-

*14. Transfer oil (i-AWD)

-

-

-

-

R

-

-

-

-

R

-

-

-

*15. Rear differential oil (i-AWD)

-

-

-

-

R

-

-

-

-

R

-

-

-

16. Steering system

Steering wheel movement,

*linkage

-

I

-

I

-

I

-

I

-

I

-

I

-

17. Power steering (if equipped)

-

I

-

I

-

I

-

I

-

I

-

I

-

18. All latches, hinges and locks

-

I

-

I

-

I

-

I

-

I

-

I

-

19. Air conditioner filter element (if equipped)*¹

-

I

-

I

-

I

-

I

-

R

-

I

-

7-9

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

miles (x 1000)

42

45

48

51

54

57

60

63

66

69

72

75

Interval: This interval should be judged by odometer

km (x 1000)

70

75

80

85

90

95

100

105

110

115

120

125

reading or months, whichever comes first.

months

42

45

48

51

54

57

60

63

66

69

72

75

CHASSIS AND BODY

1. Clutch (for manual transaxle)

Pedal and fluid level

-

I

-

-

-

-

I

-

-

-

-

I

*2. Brake discs and pads

(front, rear)

-

-

I

-

-

-

I

-

-

-

I

-

*3. Brake hoses and pipes

-

-

I

-

-

-

I

-

-

-

I

-

4. Brake fluid level check, *replacement

-

I

-

-

-

-

R

-

-

-

-

I

5. Brake pedal stroke check, *adjustment

-

I

-

-

-

-

I

-

-

-

-

I

6. Parking brake lever and *cable

Lever movement check, *adjustment

-

I

-

-

-

-

I

-

-

-

-

I

7. Tires (including tire rotation)

I

-

I

-

I

-

I

-

I

-

I

-

8. Wheel discs

I

-

I

-

I

-

I

-

I

-

I

-

*9. Wheel bearings

-

-

I

-

-

-

I

-

-

-

I

-

*10. Suspension system

I

-

I

-

I

-

I

-

I

-

I

-

*11. Propeller shafts (i-AWD)/Drive axle boots

I

-

I

-

I

-

I

-

I

-

I

-

*12. Manual transaxle oil Level check & replacement

Genuine “SUZUKI GEAR OIL 75W-80”

-

R

-

-

-

-

I

-

-

-

-

I

Other than “SUZUKI GEAR OIL 75W-80”

-

R

-

-

-

-

R

-

-

-

-

R

13. Continuously variable transaxle (CVT)

Fluid level

-

I

-

-

-

-

I

-

-

-

-

I

*Fluid deterioration check*

2

-

I

-

-

-

-

I

-

-

-

-

I

*Fluid hose

-

I

-

-

-

-

-

-

-

-

-

-

*14. Transfer oil (i-AWD)

-

R

-

-

-

-

R

-

-

-

-

R

*15. Rear differential oil (i-AWD)

-

R

-

-

-

-

R

-

-

-

-

R

16. Steering system

Steering wheel movement,

*linkage

I

-

I

-

I

-

I

-

I

-

I

-

17. Power steering (if equipped)

I

-

I

-

I

-

I

-

I

-

I

-

18. All latches, hinges and locks

I

-

I

-

I

-

I

-

I

-

I

-

19. Air conditioner filter element (if equipped)*¹

I

-

I

-

I

-

R

-

I

-

I

-

NOTE:

This table shows the service schedule up to 125000 km (75000 miles).

Beyond 125000 km (75000 miles), perform the same services at the same intervals shown in the chart.

*¹ Clean more frequently if the air flow from the air conditioner decreases.

*² Check or replace as necessary if you usually drive with high speed or high engine revolutions.

7-10

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

Periodic Maintenance Schedule for CANADA

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

Interval: This interval should be judged by

miles (x 1000)

3

6

9

12

15

18

21

24

27

30

33

36

39

odometer reading or months, whichever

km (x 1000)

5

10

15

20

25

30

35

40

45

50

55

60

65

comes first.

months

3

6

9

12

15

18

21

24

27

30

33

36

39

ENGINE & EMISSION CONTROL

1. Drive belt

Inspect for damage

-

-

-

-

-

-

-

-

-

I

-

-

-

*2. Valve lash (clearance)

-

-

-

-

-

-

-

-

-

-

-

-

-

3. Engine oil and oil filter

R

R

R

R

R

R

R

R

R

R

R

R

R

*4. Cooling system hoses and connections

-

-

-

-

I

-

-

-

-

I

-

-

-

5. Engine coolant

SUZUKI LLC: Standard (Green)

-

-

-

-

-

-

-

-

-

R

-

-

-

SUZUKI LLC: Super (Blue) (#1)

First time only: Replace at 150000 km (90000 miles) or 90 months

Second time and after: Replace every 75000 km (45000 miles) or 45 months

*6. Exhaust pipes and mountings

-

-

-

-

I

-

-

-

-

I

-

-

-

*7. EVAP canister

Replace every 250000 km (150000 miles) or 180 months

*8. Emission-related hoses & tubes

-

-

-

-

-

-

-

-

-

-

-

-

-

9. Spark plugs

-

-

-

-

-

-

-

-

-

-

-

-

-

*10. Ignition coil (plug cap)

-

-

-

-

-

-

-

-

-

I

-

-

-

*11. Fuel tank & cap

-

-

-

-

I

-

-

-

-

I

-

-

-

12. Air cleaner filter element (paved road)

I

I

I

I

I

I

I

I

I

R

I

I

I

*13. Fuel filter

Replace every 250000 km (150000 miles) or 150 months

*14. Fuel lines and connections

-

-

-

-

I

-

-

-

-

I

-

-

-

*15. Canister air suction filter

-

-

-

-

-

-

-

-

-

-

-

-

-

#1: Be sure to perform the engine coolant level check under the daily inspection in “OPERATING YOUR VEHICLE” section.

If you replace the engine coolant other than the SUZUKI LLC: Super (Blue), follow the schedule of SUZUKI LLC: Standard (Green).

7-11

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

Interval: This interval should be judged by

miles (x 1000)

42

45

48

51

54

57

60

63

66

69

72

75

odometer reading or months, whichever

km (x 1000)

70

75

80

85

90

95

100

105

110

115

120

125

comes first.

months

42

45

48

51

54

57

60

63

66

69

72

75

ENGINE & EMISSION CONTROL

1. Drive belt

Inspect for damage

-

-

-

-

-

-

I

-

-

-

-

-

*2. Valve lash (clearance)

-

-

-

-

-

-

I

-

-

-

-

-

3. Engine oil and oil filter

R

R

R

R

R

R

R

R

R

R

R

R

*4. Cooling system hoses and connections

-

I

-

-

-

-

I

-

-

-

-

I

5. Engine coolant

SUZUKI LLC: Standard (Green)

-

-

-

-

-

-

R

-

-

-

-

-

SUZUKI LLC: Super (Blue) (#1)

First time only: Replace at 150000 km (90000 miles) or 90 months

Second time and after: Replace every 75000 km (45000 miles) or 45 months

*6. Exhaust pipes and mountings

-

I

-

-

-

-

I

-

-

-

-

I

*7. EVAP canister

Replace every 250000 km (150000 miles) or 180 months

*8. Emission-related hoses & tubes

-

-

-

-

-

-

I

-

-

-

-

-

9. Spark plugs

-

-

-

-

-

-

R

-

-

-

-

-

*10. Ignition coil (plug cap)

-

-

-

-

-

-

I

-

-

-

-

-

*11. Fuel tank & cap

-

I

-

-

-

-

I

-

-

-

-

I

12. Air cleaner filter element (paved road)

I

I

I

I

I

I

R

I

I

I

I

I

*13. Fuel filter

Replace every 250000 km (150000 miles) or 150 months

*14. Fuel lines and connections

-

I

-

-

-

-

I

-

-

-

-

I

*15. Canister air suction filter

-

-

-

-

-

-

-

-

-

-

-

R

#1: Be sure to perform the engine coolant level check under the daily inspection in “OPERATING YOUR VEHICLE” section.

If you replace the engine coolant other than the SUZUKI LLC: Super (Blue), follow the schedule of SUZUKI LLC: Standard (Green).

7-12

-------------------------------------------------------------------------------------------------------------------------------------------------------------

INSPECTION AND MAINTENANCE

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

miles (x 1000)

3

6

9

12

15

18

21

24

27

30

33

36

39

Interval: This interval should be judged by odometer

km (x 1000)

5

10

15

20

25

30

35

40

45

50

55

60

65

reading or months, whichever comes first.

months

3

6

9

12

15

18

21

24

27

30

33

36

39

CHASSIS AND BODY

1. Clutch (for manual transaxle)

Pedal and fluid level

-

-

-

-

I

-

-

-

-

I

-

-

-

*2. Brake discs and pads

(front, rear)

-

I

-

I

-

-

-

I

-

-

-

I

-

*3. Brake hoses and pipes

-

I

-

I

-

-

-

I

-

-

-

I

-

4. Brake fluid level check, *replacement

-

-

-

-

I

-

-

-

-

I

-

-

-

5. Brake pedal stroke check, *adjustment

-

-

-

-

I

-

-

-

-

I

-

-

-

6. Parking brake lever and *cable

Lever movement check, *adjustment

-

I

-

-

I

-

-

-

-

I

-

-

-

7. Tires (including tire rotation)

-

I

-

I

-

I

-

I

-

I

-

I

-

8. Wheel discs

-

I

-

I

-

I

-

I

-

I

-

I

-

*9. Wheel bearings

-

-

-

I

-

-

-

I

-

-

-

I

-

*10. Suspension system

-

I

-

I

-

I

-

I

-

I

-

I

-

*11. Propeller shafts (i-AWD)/Drive axle boots

-

I

-

I

-

I

-

I

-

I

-

I

 

 

 

 

 

 

 

Content      ..     15      16      17      18     ..