Instrument Cluster Rear End

1

2

3

FE11-2018b

Legend

1. Instrument Cluster Wiring Harness Connector (32-Pin

Blue)

2. Buzzer

3. Multi-Meter Wiring Harness Connector (12-Pin White)

Body Electric

Instrument / Driver Information System

11-285

11.7.5 Schematic
11.7.5.1 Schematic

11-286

Instrument / Driver Information System

Body Electric

11.7.6 Diagnostic Information and Procedures
11.7.6.1 Diagnosis Description

The instrument supports CAN-based bus OBD and standard KWP2000 protocol.

OBD can be K-wire serial communications and CAN communications.

Refer to

11.7.2

 

Description and Operation

get familiar with the system functions and operation before start system diagnostics, so

that it will help to determine the correct diagnostic steps, more importantly, it will also help to determine whether the customer
described situation is normal.

11.7.6.2 Visual Inspection

–

Check installed after market equipment that may affect system operation.

–

Check the easy to access system components to identify whether there is a significant damage or a potential malfunction.

–

Check whether all sensors are normal.

11.7.6.3 Fault Diagnostic Code (DTC) List

DTC code

Description

U1303

Fuel sensor input signal circuit high-voltage, or the wiring harness connector is disconnected

U1304

Fuel sensor input signal circuit is short to ground.

U129C

Meter voltage is higher than normal.

U129D

Meter voltage is lower than normal.

U150F

EEPROM Checksum Error

U1400

ABS Message Time Out, ABS Communication Lost

U1410

airbag control module Message Time Out, airbag control module Communication Lost

U1420

BCM Message Time Out, BCM Communication Lost

U1430

EMS Message Time Out, EMS Communication Lost

U1501

CAN Network System Integrity Test Failure

U1601

CAN Bus Off

11.7.6.4 Instrument Active Test List

Test Parts

Test Items

Buzzer Test

Door Buzzer

Seat Belt Beep

Reverse Radar Buzzer

Key Does Not Pull Buzzer

Lights Are Not Off Beep

LCD Test

Vertical Section, Horizontal Section

Special Section, Symbols

Body Electric

Instrument / Driver Information System

11-287

Test Parts

Test Items

LCD Test

Remove All

Digital Output

Driver Seat Belt Warning

Passenger Seat Belt Warning

ABS Warning

Low Fuel Warning

Coolant Temperature Warning

Left Turn Signal

Right Turn Signal

Hood Open Warning

Trunk Open Warning

EBD Alarm

Airbag Alarm

MIL Alarm

11.7.6.5 Meter Terminal List

15 14 13  12  11 10 9 8 7  6 5 4 3 2 1 

16 
32 31 30 29 28 27 26 25 24 23 22 21 20 19 18  17 

Instrument Cluster Harness Connector IP03

FE11-5601b

Terminal ID

Terminal Definition

Diameter / Color

Specified Conditions (Voltage,

Current, Waveform, etc.)

1

Front Fog Lamp On Signal

0.85 R/O

20 mA

2

Rear Fog Lamp On Signal

0.5 R/W

20 mA

3

Tire Pressure Management System
Malfunction Lamp

0.3W

20 mA

4

Reserved

Reserved

-

5

Low Tire Pressure Warning

0.3 L

20 mA

11-288

Instrument / Driver Information System

Body Electric