Iran Khodro Samand SE. Service Manual - part 5

70

2

ALARM

Option Menu 6: Contrast

By pressing 

 button enter menu 6(32)

In this menu you can adjust the contrast of 

the display screen.

By pressing 

  button contrast 

percentage goes up.

By pressing 

 button the contrast level 

will decrease (33).

By pressing 

 button, exit the menu.

Option Menu 7: Change of Language

Enter menu 7 by pressing 

 button(34).

71

2

ALARM

In this menu you can change the language 

to Farsi, Arabic, English or Russian by 

using 

 and 

 buttons (35).

By pressing 

  button all messages, 

commands and voice messages will be 

displayed in the chosen language.

Exit menu by pressing 

 button.

Option Menu 8:  Default Settings

Enter menu 8 by pressing 

 button(36).

By selecting this option and pressing the 

  button  the  message  “confirm  the 

changes” appears on the screen (37).

If 

 button is pressed once again, the 

changes  will  be  confirmed  and  if   

 

button is pressed, changes will not be 

taken into account. The sensitivity of the 

shock sensor and the display contrast will 

return to default settings.

The inside temperature control will return 

to manual.

72

2

* If equipped

THEFT DETERENT ALARM

Theft deterrent alarm *

Arming 

The theft deterrent alarm will be armed 

after you lock the doors using the remote 

controller while the ignition key is in initial 

mode and all vehicle’s doors (including 

engine hood and trunk lid) are closed. 

When theft deterrent alarm is armed, the 

turn signal lights blinks and one alarm* is 

heard.

Central lock key light on the instrument 

panel start blinking when the theft Deterrent 

Alarm is armed.

Once the is armed, occurrence of any of 

the followings will cause the alarm to be 

triggered (turn signal lights and alarm 

come on):

-Opening of any doors (including engine 

hood and trunk lid)

-Unlocking of front doors by key

-Changing the position of the starter switch

Alarm will continue for 30 seconds. Then 

the alarm is stopped for 5 seconds. 

Should the cause of the alarm situation 

is eliminated, the turn signal lights and 

alarm* go out and otherwise the alarm will 

continue.

This cycle goes on with 10 times, then the 

turn signal lights and alarm* goes out, but 

the theft deterrent alarm stays armed.

Disarming theft deterrent alarm

When the antitheft alarm is activated; 

doors will be opened and the theft 

deterrent alarm will be disarmed,just by 

pressing the unlock key on the remote 

control. Driver will be awared of this 

 

function while the indicator lamps are 

being turned off and on twice.

We can Inactivate the anti theft alarm by 

the ignition switch (and not necessarily by 

remote controller ) while we’re locking the 

doors.

This approach is suitable for those 

vehicles in which the horn is used for anti 

theft alarm; specially when the vehicle is 

parked in a safe place for a long period of 

time and there is worries of unnecessary 

hearing the noise of alarm (Horn sound).

Dome light

1-The dome light comes on when one 

of the vehicle’s doors (including side 

doors and trunk lid and engine hood) are 

opened, while the engine is off.

2-Dome light comes on by pushing the 

unlock key, while the theft deterrent alarm 

is armed.

3-In case the dome light is on and all 

doors are closed:

-After 12 seconds

-Upon pushing lock key

-Auto-lock key

-Starter switch changes to 1 position or 

higher, and then after 4 seconds the dome 

light fades out.

 

73

2

THEFT DETERENT ALARM

* If equipped

4- If any of the vehicle’s doors (such as 

trunk lid and engine hood) are open at the 

time of driving, roof light blinks and informs 

the driver.

Notice

-In Case even one of the doors to is 

open, theft deterrent alarm will not be 

armed. This situation is indicated by 

four time blinking of the turning lights 

and 4 continuous alarms. *

-When theft deterrent alarm is armed, 

it the trunk lid unlock by remote 

control, you may open the trunk 

lid, take something from it or put 

something in it and then close trunk 

lid within 30 seconds. If it takes more 

than 30 seconds, theft deterrent alarm 

starts alarming.

-When theft deterrent alarm is triggered, 

you may stop direction lights and alarm 

by pushing any of the lock or unlock 

keys on the remote control, but this 

does not open the vehicle’s doors and/

or disarming theft deterrent alarm.

74

2

THEFT DETERENT ALARM

Caution

- Avoid parking your car in unattended 

on- street parking spaces.

- Avoid parking in dark places.

- Never leave the car’s documents or 

spare keys in your vehicle.

- Park in your garage if you have one, 

and take the switch with you. 

Safety tips for preventing vehicle theft 

Always follow the tips mentioned here 

when you are leaving the vehicle even if 

for a few minutes:

1- Close all windows completely.

2- Take your valuable objects with you or 

hide them in the trunk.

3- Do not leave your keys.

4- Lock the steering wheel ( when the car 

is not running, the steering wheel could be 

easily locked by a little turn)

5-Lock all the doors. 

In addition you can think of other ways to 

minimize the risk of car theft.

75

2

* If equipped

CNG FUELING SYSTEM

CNG system:

Engine compartment overview *

1. Regulator:

 Reduces the gas 

pressure from a maximum of 200 bar to 

7bar.

2. Hose (transferring gas to fuel 

rail): 

Transfers the reduced pressure gas 

from the regulator to the fuel rail.

3. Fuel Rail:

 Gas entering the manifold 

passes through the fuel rail, and enters 

the manifold when the gas injectors open 

in the indicated times.

4 & 5. Input/ Output Hot Water 

Hoses (Regulator):

 Transfers the 

heater water to the regulator to warm up 

and to prevent the regulator from freezing 

when operating on gas mode.

6. High Presuure Gas pipe:

 Transfer 

gas from gas trunk to regulator.

7. Electrical Control Unit (ECU):

 

Adjusts the moment and time length 

of injector sprinkling and the timing of 

sparking in different engine conditions.

*Engine Volume = 1700 cc gas
  Engine type = EF7

76

2

CNG FUELING SYSTEM

Cng fueling system

1. Tank (Tanks): CNG is contained by 

200 bar pressure at highest.

2.Tank Valve: Limits and opens the 

gas passage at the end of the tank, and 

includes equipment which evacuate 

the gas tank when gas pressure and 

temperature exceeds the standard limit. If 

the pipes are cut, it limits the gas escape 

from the tank.

3. Pipes & Gas Ventilation System:

Ventilation system transfer the gas 

outside the trunk if any leakages happen 

in connections.

4. Filler:

It is a part installed on the automobile for 

fueling the gas tank and it is connected to 

the fuel nozzle in the gas station.

77

* If equipped

DRIVING

3

DIGITAL INSTRUMENT PANEL  ........................................  78-86

AUDIO ALARMING ON INSRTRUMENT PANEL*  ................ 80

CRUISE CONTROL*  ................................................................ 85

STARTING & DRIVING  ............................................................ 90 

MANUAL GEARBOX   .............................................................. 91

FUEL ECONOMY & ENVIRONMENT  ..................................... 92 

STARTING & DRIVING (CNG MODE)*  ................................... 93

REVERSING GEAR ALARMING*  ........................................... 96 

FUEL   ......................................................................................... 97

CNG FUELING STEPS*  ........................................................... 98 

LAMPS / INDICATORS  ............................................................ 99 

HORN  ........................................................................................ 99

WINDSCREEN WASHER & WIPER  ..................................... 101 

BRAKES  .................................................................................. 102

ANTI-LOCK BRAKING (ABS)   ...............................................103

AIR BAG*  ................................................................................ 105

PASSENGER AIR BAG  ......................................................... 107

78

3

INSTRUMENT PANEL 

Fuel gauge

The pointer falls to zero when the ignition 

switch is off, but it shows the tank fuel level 

when the switch gets on.

A warning indicator light in the fuel gauge 

lights up when the fuel level falls to 7 litters.

Refuel as soon as possible. Fuel tank 

capacity is 66 liters.

Tachometer

 It shows the engine speed in revolutions 

per minute. To avoid engine damage, 

never let the tachometer pointer remain in 

red section for a long time.

Speedometer

It shows the speed of vehicle in Km/h.

Coolant temperature gauge

This gauge indicates the temperature 

of the engine coolant, When the engine 

warms up, the pointer rises to the middle 

of the gauge, and it remains until the 

engine operates in normal condition.

If the pointer reaches the red section, it 

shows that coolant is overheated causing 

damage to the engine. In this situation stop 

the vehicle immediately considering safety 

conditions  and  seek  help  from  qualified 

persons to repair.

Possible causes

- A faulty fan- Check fuses, and change 

them if necessary.

-The coolant system leakage; let the engine 

cool down, and then check the coolant 

liquid level.

-A fault in the water pump operation

Distance recorder reset button 

(Trip recorder reset button)

It is used to show different situations in the 

digital display panel and reset information 

in the related condition.

79

3

* If your vehicle is equiped 

INSTRUMENT PANEL 

Instrument panel (1) 

Warning Lamps/Signals Above  picture : 

1- Low Fuel Level + Warning 

2- Fuel Gauge 

3- Immoblizer light

4- CNG Fueling indicator*

5- Cruise Control indicator* 

6- Head lamp dipped light

7- Head lamp beam light 

8- Diagnostic warning lamp 

9- Indicator of Cooling system liquid temprature 

10- High Coolant Temperature

Instrument Panel (2) 

Warning Lamps/Instruments Below picture: 

1- Air bag deactivation warning lamp 

2- Tachometer 

3- Left Indicator

4- Right Indicator 

5- CNG reservoir pressure indicator 

6- Speedometer 

7- Trip Recorder Zero Reset 

8- Instrument panel adjustor ley

9- Periodic service warning lamp 

10- Rear Fog Lamps 

11- Fueling direction indicator

12- 12- ABS indicator

13- ABS- EBD system warning

14- Air bag malfunctioning warning lamp

80

3

* If equipped

INDICATORS OF THE INSTRUMENT PANEL

Direction indicators - 

green

The directions of indicators 

(turning to the right and turning to the left) 

are defined by arrows. When you turn on 

the left or right signals, the corresponding 

green arrow on the instrument panel will 

flash along with the respective turn signal 

lights.

If the flasher (hazard warning light) is used, 

both  indicators  flash  together.  If  either 

warning light flashes very rapidly, this means 

that the corresponding direction indicator is 

not operating.

Notice: This situation occurs only when 

one of the front or rear direction lights 

does not work properly, but if one of the 

side lights is not working, it will have no 

effect on the warning light flash frequency. 

When you turn on the direction lights, lights 

on folding mirrors will flash simultaneously 

with related flasher*.

Important  note: If the vehicle 

experiences an excessive speed fall, the 

alarm system automatically turns on the 

flasher for 10 seconds.

This is a warning sign for excessive speed fall.

Headlamp dipped beam - Green

It lights up when using dipped 

(dimmed) headlights

Headlamp main beam – Blue

It lights up when using main-

beam headlights

Front fog lamp – Green*

It lights up when using front fog lights.

Rear fog lamp – Orange

It lights up when using rear fog lights.

Low fuel level warning

Next to the fuel gauge there is a 

warning light, when the light is on it shows 

that less than 7 liters of fuel remains in the 

fuel tank. Refuel as soon as possible.

Theft deterrent - red

It indicates that the theft deterrent 

system is activated when blinking.

Engine diagnostic function – 

Orange

This warning light comes on when the 

engine  performance  tester  finds  any 

problem in the engine. When the starter 

switch is in second (ON) position, this 

light comes on to indicate it is testing 

performance of the engine and goes out 

after engine being started. Should any 

problem arise in engine during driving this 

light comes on again.

Note:

- If the  warning light comes on but the 

vehicle functions are normal, you may 

continue driving but should refer to an 

authorized dealer.

- If the warning light comes on and the 

vehicle functions are not normal, you may 

not drive high speed and should refer to 

an authorized dealer immediately.

- If the warning light blinks, it means there 

is a problem in the ignition system .In this 

case Make the engine to work in low RPM 

and refer to the authorized dealer of IKCO 

as soon as possible.*

High coolant temperature 

warning – red

This indicator is next to thermometer. 

When the thermometer is on red position,  

the indicator is on. 

When the indicator is on stop immediately 

(engine on) and refer to an authenticated 

dealer. In the case of high temperature, 

(STOP) indicator on.

81

3

INDICATORS OF THE INSTRUMENT PANEL

Engine oil level warning 

light - red 

When the starter switch is in second 

position, the light comes on briefly, so you 

can check that the light is working. When 

the engine is started, the indictor goes out. 

In case engine oil level warning lights stays 

on and/or comes on during vehicle function, 

it indicates the engine is in critical situation, 

oil pressure is not enough and/or it is low in 

lubricating system. 

Stop immediately

, 

while observing all safety precautions, and 

switch engine off. Consult with authorized 

dealer before running the vehicle again.

Cruise-control - Orange*

By turning on or off, this indicator 

shows activation or deactivation of the 

cruise-control.

Battery charge warning 

light – red

When the starter switch is in second 

position, the light comes on briefly, so you 

can check that the light is working. When 

the engine is started, the indicator goes 

out. Should it remains on after starting 

engine or comes on during driving; there 

may be a problem in the battery charge 

system. Refer to authorized dealer as 

soon as possible.

Following situations causes this warning 

comes on:

- Fault in battery charge system

- Fault in battery or its terminals

- Fault in alternator

- Fault in alternator’s wires

Brake Alarm – Red

This indicator is turned on for a few 

seconds while starting the engine and then it 

turns off, and it turns on when the hand brake 

slides up or when the brake fluid level is low. 

If the indicator of brake system alarm doesn’t 

work or remains on while starting the vehicle or 

after sliding down of hand brake, without delay 

fill the brake liquid reservoir and if the indicator 

remains on after filling the reservoir and sliding 

down of the hand brake, while considering 

safety precautions, transfer the vehicle to an 

authorized workshop for evaluation and repair.

Driver Safety Belt – Red

By locking of the metal tongue of 

the driver safety belt in the special buckle 

and with a “click”, we make sure of its 

locking. With this action the indicator on 

the panel is turned off.

If the seat belt is not fastened, this light gets 

on along with audio alarming for one minute 

the warning light is displayed only. The 

audio alarming will be heard again, when 

the speed of vehicle exceeds 20 km/h.

Anti – Lock Brake System 

Warning (ABS) – Orange

It lights up when starting the car and keeps 

on for a few seconds, and then it turns off. If 

it does not turn on when starting the engine 

or stays on after the engine starts running, 

it indicates that there is a problem in the 

anti-lock brake system and or EBD. In such 

a condition move the car immediately and 

with safety considerations to the authorized 

workshop for inspection and repair.

* If equipped

82

3

INDICATORS OF THE INSTRUMENT PANEL

Instant stop warning

Should this indicator lights on, 

stop immediately and switch off the 

engine. Contact with dealer or  authorized 

representative. The  indicator light also 

comes on to warn the engine oil pressure 

and battery charge.

The indicator may also gets on to warn 

the engine oil level is low or the engine 

coolant temperature high

Warning

If the 

 light comes on for any 

reason, driver should stop the vehicle. 

In case he continues driving, vehicle 

owner will be responsible for any 

resulted damages.

Warning of driver air bag 

defect – orange

The indicator comes on when you start 

the vehicle and blinks on for 6 times and 

then should go out. In Case this light 

stays on, it indicates there is a fault in 

driver air bag system. You should refer to 

authorized dealer as soon as possible, or 

all responsibilities rest on owner.

CNG fuel position indicator 

– Green*

The indicator turns on when CNG fuel 

position activated.

If fuel consumption changes from gasoline 

to CNG the indicator blinks.

Note

If CNG indicator is blinking continually and 

gasoline mode is not converted to gas even 

after warming up the engine; then there is a 

fault in one part of CNG system and should 

contact to an authenticated dealer. (for 

details, refer to Starting and Driving - CNG )

Doors open- Red

This indicator shows that at least 

one of the doors is opened. The indicator 

operates even the engine off. Avoid driving 

when the indicator on.

Driver safety belt - Red

By locking of the metal tongue of 

the driver safety belt in the special buckle 

and with a “click”, we make sure of its 

locking. With this action the indicator on 

the panel is turned off.

Digital display screen guide

1

- When the ignition switch is turned to “ON” the 

display shows odometer. odometer records the 

total distance (km) the vehicle has been driven 

since being delivered to the owner. The trip meter 

could not be reset to zero (if it has been set on this 

situation, otherwise it could be observed when the 

ignition switch is in “OFF” position).

2- Trip meter indicates the distance (km) the 

vehicle has been driven since it has been reset 

to zero. Push reset button for 2 second to reset 

the distance to zero.

3- This indicates the pressure of the gas in the 

LCD and is made of 6 black stripes. When gas 

pressure is full the 6 stripes are active and by 

decreasing the gas pressure the number of 

these stripes decreases. Gas tank insufficient 

pressure warning is indicated by the flashing of 

the first stripes in LCD. When the gas pressure 

become zero the last stripes goes off.*

* If equipped

83

3

* If equipped

INDICATORS OF THE INSTRUMENT PANEL*

Instrument panel (1)

Warning and alarm lights

1- Low fuel warning light

2- Fuel level indicator

3- Immobilizer system light

4- Activation of CNG fuel system indicator*

5- Cruise control indicator light*

6- Low beam 

7- Head lamp main beam.

8- Malfunction warning light

9- Engine coolant temperature indicator light 

10- Front fog light

Indicators and gauges lights (2)

1- Air bag deactivation warning light* (front 

passanger)

2- Tachometer

3- Left turn signal light

4- Right turn signal light

5- CNG pressure indicator*

6- Speedometer

7- Change mode and reset key

8- Turning knob for setting the instrument panel

9- Periodical maintenance warning light

10- Rear fog light

11- Fueling indicator

12- ABS brake indictor

13- Driver air bag fault warning light

Instrument panel*

84

3

* If equipped

INDICATORS OF THE INSTRUMENT PANEL*

Direction indicators - 

green

The directions of indicators 

(turning to the right and turning to the left) 

are defined by arrows. When you turn on 

the left or right signals, the corresponding 

green arrow on the instrument panel will 

flash along with the respective turn signal 

lights.

If the flasher (hazard warning light) is used, 

both indicators flash together. At the time of 

activation of direction lights. If either warning 

light  flashes  very  rapidly,  this  means  that 

the corresponding direction indicator is not 

operating.

Notice: This situation occurs only when 

one of the front or rear direction lights 

does not work properly, but if one of the 

side lights is not working, it will have no 

effect on the warning light flash frequency. 

When you turn on the direction lights, lights 

on folding mirrors will flash simultaneously 

with relevant flasher*.

Important  note: If the vehicle 

experiences an excessive speed fall, the 

alarm system automatically turns on the 

flasher for 10 seconds.

This is a warning sign for excessive speed fall.

Headlamp dipped beam - Green

It lights up when using dipped 

(dimmed) headlights

Headlamp main beam – Blue

It lights up when using main-

beam headlights

Front fog lamp – Green

It lights up when using front fog lights.

Rear fog lamp – Orange

It lights up when using rear fog lights.

Low fuel level warning - Red

This light indicates that remaining 

fuel in the tank is less than 8 liters. Refuel 

as soon as possible. This indicator starts 

blinking when the fuel is less than 3 liters.

Engine performance tester – 

Orange

This warning light comes on when the 

engine  performance  tester  finds  any 

problem in the engine. When the starter 

switch is in second (ON) position, this 

light comes on to indicate it is testing 

performance of the engine and goes out 

after engine being started. Should any 

problem arise in engine during driving this 

light comes on again.

Note:

-If the  warning light comes on but the 

vehicle functions are normal, you may 

continue driving but should refer to an 

authorized dealer.

-If the warning light comes on and the 

vehicle functions are not normal, you may 

not drive high speed and should refer to 

an authorized dealer immediately.

-If the warning light blinks, it means there 

is a problem in the spark system; and the 

engine must be worked in a low RPM 

and taken to authorized representative of 

IKCO soon.

85

3

INSTRUMENT PANEL DISPLAY INDICATORS*

Anti – Lock Brake System 

Warning (ABS) – Orange

It lights up when starting the car and keeps 

on for a few seconds, and then it turns off. If 

it does not turn on when starting the engine 

or stays on after the engine starts running, 

it indicates that there is a problem in the 

anti-lock brake system and or EBD. In such 

a condition move the car immediately and 

with safety considerations to the authorized 

workshop for inspection and repair.

Warning of deactivity of the 

Passenger air bag – orange

If this light comes on it indicate the 

passenger air bag is deactive. As long as 

the  passenger  airbag  is  deactive,  the  light                                

ins lit. In case the blinking warning light 

comes on, you should contact with one of 

the authorized Iran Khodro dealer.

Warning of driver air bag 

defect – orange

The indicator comes on when you start 

the vehicle and blinks on for 6 times and 

then should go out. In Case this light 

stays on, it indicates there is a fault in 

driver air bag system. You should refer to 

authorized dealer as soon as possible, or 

all responsibilities rest on owner.

Cruise control - Orange*

By turning on or off, this indicator 

shows activation or deactivation of the 

cruise-control.

Immobilizer light – Orange

Blinking these lights every 4 

seconds once after turning off the car, 

means that the immobilizer system is 

active.

Service warning light –Orange

When this light comes on it means 

there is a fault in one of the vehicle’s 

system or periodic maintenance is due.

When the light on, refer to the nearest 

center of after sale services.

* If equipped