SsangYong Rodius (2013 year). Manual - part 43

 

  Index      SsangYong     SsangYong Rodius - service repair manual 2013 year

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  41  42  43  44   ..

 

 

SsangYong Rodius (2013 year). Manual - part 43

 

 

02-12

5. GUIDELINES ON ENGINE SERVICE

To prevent personal injuries and vehicle damages that can be caused by mistakes during engine and 

unit inspection/repair and to secure optimum engine performance and safety after service works, basic 

cautions and service work guidelines that can be easily forgotten during engine service works are 

described in.

Cautions before service works

For safe and correct works, you must observe the working procedures and instructions in this 

manual. And, use the designated tools as follow:

Engine stand / Heavy duty engine jack

To prevent the engine from starting abruptly, do not allow anybody to get in the vehicle while 

servicing in engine compartment.

Before work on engine and each electrical equipment, be sure to disconnect battery negative (-) 

terminal.

Before service works, be sure to prepare the works by cleaning and aligning work areas.

Do not allow the foreign material get into the fuel injection system.

When removing the engine, use only the safety hook on engine and engine hanger. Do not 

support the bottom of oil pan with a jack.

Engine and accessories

Completely drain the engine oil, coolant and fuel from engine before removal.

Before disassembling/assembling the engine components, carefully read the working procedures 

in this manual.

Make sure to keep the specified tightening torques during installation.

Clean and properly lubricate the parts before reassembly.

Carefully check that there are not any interference while servicing.

-

-

-

-

-

-

-

-

-

-

-

02-13

0000-00

Electrical equipment

Electric devices should be handled more carefully.

Currently, the engine has a lot of electric devices. there could be poor engine performance, incomplete 

combustion and other abnormal symptoms due to short circuit or poor contact.

Before work on engine and each electrical equipment, be sure to disconnect battery negative (-) 

terminal.

When replacing the electric device, use only genuine part and check the conditions of connections 

and grounds. Loosened connection or ground make cause a fire and personal injury.

-

-

Fuel and lubrication system

Do not allow the fluid and engine oil to make contact with the body paintwork and hoses.

If work on the fluid system such as fuel and oil, working area should be well ventilated and smoking 

should be prohibited.

Gasket or seal on the fuel/lubrication system should be replaced with new ones and bolts and nuts 

should be tightened as specified.

After removal/installation works, be sure to check whether there is leak on the connecting section.

-

-

-

-

If fine dust or foreign material enters into DI engine's fuel system, there can be serious damages in HP 

pump and injectors. Thus, be sure to plug the inlets of removed fuel line components with cap and 

protect removed parts not to be contaminated with dirt. (Refer to cleanness in this manual while 

working on DI engine fuel system)

02-14

D20DTR Engine

1. BELT LAYOUT

It is single drive type and uses FEAD (Front End Accessories Drive) design to make a compact layout.

Components

HPS

(Hydraulic Power Steering)

Crankshaft pulley (DDU)

2 Auto 

tensioner

3 Tensioner 

pulley

4 Vacuum 

pump

A/C compressor pulley

6 Alternator 

pulley

Water pump pulley

Idle pulley #1

Idle pulley #2

10 

Power steering pump pulley

02-15

0000-00

The strut type tensioner automatically adjusts the belt tension to provide the reliability and durability for 

the system. And, the belt tension is decreased to minimize the friction loss and improve the belt 

operating noise.

1) Crankshaft Pulley (Isolation Damper)

(1) Overview

(2) Sectional drawing

Axial & radial bearing

Sleeve

Hub

Isolation pulley rubber

Pulley

Damper rubber

Inertia ring

 

 

 

 

 

 

 

Content   ..  41  42  43  44   ..