Nissan Quest E52. Manual - part 599

EXHAUST SYSTEM

EX-7

< REMOVAL AND INSTALLATION >

C

D

E

F

G

H

I

J

K

L

M

A

EX

N

P

O

3.

After installing, check that bolt does not interfere with mounting hole of center muffler.

Inspection

INFOID:0000000009650912

INSPECTION AFTER INSTALLATION

• Check clearance between tail tube and rear bumper is even at right and left.
• With engine running, check exhaust tube joints for gas leakage and unusual noises.
• Check to ensure that mounting brackets and mounting rubbers are installed properly and free from undue

stress. Improper installation could result in excessive noise and vibration. 

EXL-1

DRIVER CONTROLS

C

D

E

F

G

H

I

J

K

M

SECTION 

EXL

A

B

EXL

N

O

P

CONTENTS

EXTERIOR LIGHTING SYSTEM

XENON TYPE

PRECAUTION ...............................................

6

PRECAUTIONS ...................................................

6

Precaution for Supplemental Restraint System 
(SRS) "AIR BAG" and "SEAT BELT PRE-TEN-
SIONER" ...................................................................

6

Precautions For Xenon Headlamp Service  ...............

6

Precautions for Removing Battery Terminal  .............

7

SYSTEM DESCRIPTION  ..............................

8

COMPONENT PARTS  ........................................

8

Component Parts Location ........................................

8

Optical Sensor ...........................................................

9

Daytime Running Light Relay ....................................

9

Xenon Headlamp  ......................................................

9

Hazard Switch  .........................................................

10

Headlamp Aiming Switch  ........................................

10

HID control unit  .......................................................

10

Headlamp Aiming Motor ..........................................

10

Bulb Specifications ..................................................

11

SYSTEM .............................................................

12

HEADLAMP SYSTEM  ...............................................

12

HEADLAMP SYSTEM : System Description ...........

12

HEADLAMP SYSTEM : Circuit Diagram  .................

13

HEADLAMP SYSTEM : Fail-safe ............................

13

AUTO LIGHT SYSTEM (EXCEPT FOR CANADA) 

....

14

AUTO LIGHT SYSTEM (EXCEPT FOR CANADA) 
: System Description  ...............................................

14

AUTO LIGHT SYSTEM (EXCEPT FOR CANADA) 
: Circuit Diagram  .....................................................

16

AUTO LIGHT SYSTEM (FOR CANADA)  ..................

16

AUTO LIGHT SYSTEM (FOR CANADA) : System 
Description ..............................................................

17

AUTO LIGHT SYSTEM (FOR CANADA) : Circuit 
Diagram ...................................................................

19

DAYTIME RUNNING LIGHT SYSTEM  ......................

19

DAYTIME RUNNING LIGHT SYSTEM : System 
Description ...............................................................

20

DAYTIME RUNNING LIGHT SYSTEM : Circuit Di-
agram ......................................................................

21

HEADLAMP AIMING CONTROL (MANUAL) ...........

21

HEADLAMP AIMING CONTROL (MANUAL) : 
System Description ..................................................

21

TURN SIGNAL AND HAZARD WARNING LAMP 
SYSTEM .....................................................................

21

TURN SIGNAL AND HAZARD WARNING LAMP 
SYSTEM : System Description ................................

22

TURN SIGNAL AND HAZARD WARNING LAMP 
SYSTEM : Circuit Diagram  ......................................

23

PARKING, LICENSE PLATE, SIDE MARKER AND 
TAIL LAMP SYSTEM .................................................

23

PARKING, LICENSE PLATE, SIDE MARKER 
AND TAIL LAMP SYSTEM : System Description ....

23

PARKING, LICENSE PLATE, SIDE MARKER 
AND TAIL LAMP SYSTEM : Circuit Diagram  ..........

24

PARKING, LICENSE PLATE, SIDE MARKER 
AND TAIL LAMP SYSTEM : Fail-safe .....................

25

FRONT FOG LAMP SYSTEM  ...................................

26

FRONT FOG LAMP SYSTEM : System Descrip-
tion ...........................................................................

26

FRONT FOG LAMP SYSTEM : Circuit Diagram  .....

27

FRONT FOG LAMP SYSTEM : Fail-safe  ................

27

EXTERIOR LAMP BATTERY SAVER SYSTEM .......

28

EXTERIOR LAMP BATTERY SAVER SYSTEM : 
System Description ..................................................

28

EXTERIOR LAMP BATTERY SAVER SYSTEM : 
Circuit Diagram ........................................................

29

DIAGNOSIS SYSTEM (BCM)  ...........................

30

COMMON ITEM  .........................................................

30

COMMON ITEM : CONSULT Function (BCM - 
COMMON ITEM)  .....................................................

30

EXL-2

HEADLAMP ..............................................................

31

HEADLAMP : CONSULT Function (BCM - HEAD-
LAMP) (Xenon Type Headlamp)  ............................

32

FLASHER ..................................................................

34

FLASHER : CONSULT Function (BCM - FLASH-
ER) (Xenon Type Headlamp)  .................................

34

DIAGNOSIS SYSTEM (IPDM E/R)  ....................

36

Diagnosis Description  .............................................

36

CONSULT Function (IPDM E/R)  ............................

38

ECU DIAGNOSIS INFORMATION ..............

41

BCM, IPDM E/R  .................................................

41

List of ECU Reference  ............................................

41

WIRING DIAGRAM  .....................................

42

EXTERIOR LIGHTING SYSTEM  .......................

42

Wiring Diagram  .......................................................

42

BASIC INSPECTION ...................................

59

DIAGNOSIS AND REPAIR WORK FLOW  ........

59

Work Flow ...............................................................

59

DTC/CIRCUIT DIAGNOSIS .........................

62

HEADLAMP (HI) CIRCUIT  ................................

62

WITHOUT DAYTIME RUNNING LIGHT SYSTEM ...

62

WITHOUT DAYTIME RUNNING LIGHT SYSTEM 
: Component Function Check  .................................

62

WITHOUT DAYTIME RUNNING LIGHT SYSTEM 
: Diagnosis Procedure  ............................................

62

WITH DAYTIME RUNNING LIGHT SYSTEM  ...........

63

WITH DAYTIME RUNNING LIGHT SYSTEM : 
Component Function Check  ...................................

63

WITH DAYTIME RUNNING LIGHT SYSTEM : Di-
agnosis Procedure ..................................................

64

HEADLAMP (LO) CIRCUIT  ...............................

66

Component Function Check  ...................................

66

Diagnosis Procedure  ..............................................

66

DAYTIME RUNNING LIGHT RELAY CIRCUIT 

...

68

Component Function Check  ...................................

68

Diagnosis Procedure  ..............................................

68

Component Inspection ............................................

69

XENON HEADLAMP  .........................................

70

Diagnosis Procedure  ..............................................

70

HEADLAMP AIMING SYSTEM (MANUAL)  ......

71

Component Inspection ............................................

71

PARKING LAMP CIRCUIT  ................................

72

Component Function Check  ...................................

72

Diagnosis Procedure  ..............................................

72

FRONT SIDE MARKER LAMP CIRCUIT  ..........

74

Component Function Check  ...................................

74

Diagnosis Procedure ...............................................

74

TAIL LAMP CIRCUIT  ........................................

75

Component Function Check  ...................................

75

Diagnosis Procedure ...............................................

75

LICENSE PLATE LAMP CIRCUIT  ....................

77

Component Function Check  ...................................

77

Diagnosis Procedure ...............................................

77

TURN SIGNAL LAMP CIRCUIT  ........................

78

Component Function Check  ...................................

78

Diagnosis Procedure ...............................................

78

FRONT FOG LAMP CIRCUIT  ...........................

81

Component Function Check  ...................................

81

Diagnosis Procedure ...............................................

81

OPTICAL SENSOR  ...........................................

83

Component Function Check  ...................................

83

Diagnosis Procedure ...............................................

83

HAZARD SWITCH  .............................................

86

Component Function Check  ...................................

86

Diagnosis Procedure ...............................................

86

SYMPTOM DIAGNOSIS  ............................

88

EXTERIOR LIGHTING SYSTEM SYMPTOMS ...

88

WITHOUT DAYTIME RUNNING LIGHT SYSTEM ....

88

WITHOUT DAYTIME RUNNING LIGHT SYSTEM 
: Symptom Table .....................................................

88

WITH DAYTIME RUNNING LIGHT SYSTEM  ...........

89

WITH DAYTIME RUNNING LIGHT SYSTEM : 
Symptom Table .......................................................

90

NORMAL OPERATING CONDITION  ................

93

Description ..............................................................

93

BOTH SIDE HEADLAMPS (HI) ARE NOT 
TURNED ON ......................................................

94

WITH DAYTIME RUNNING LIGHT SYSTEM  ...........

94

WITH DAYTIME RUNNING LIGHT SYSTEM : De-
scription ...................................................................

94

WITH DAYTIME RUNNING LIGHT SYSTEM : Di-
agnosis Procedure  ..................................................

94

WITHOUT DAYTIME RUNNING LIGHT SYSTEM ....

94

WITHOUT DAYTIME RUNNING LIGHT SYSTEM 
: Description  ............................................................

94

WITHOUT DAYTIME RUNNING LIGHT SYSTEM 
: Diagnosis Procedure .............................................

94

BOTH SIDE HEADLAMPS (LO) ARE NOT 
TURNED ON ......................................................

96

Description ..............................................................

96

Diagnosis Procedure ...............................................

96

EXL-3

C

D

E

F

G

H

I

J

K

M

A

B

EXL

N

O

P

PARKING, LICENSE PLATE, SIDE MARKER 
AND TAIL LAMPS ARE NOT TURNED ON  ......

97

Description ..............................................................

97

Diagnosis Procedure ...............................................

97

BOTH SIDE FRONT FOG LAMPS ARE NOT 
TURNED ON .......................................................

98

Description ..............................................................

98

Diagnosis Procedure ...............................................

98

PERIODIC MAINTENANCE .........................

99

HEADLAMP AIMING ADJUSTMENT  ................

99

Description ..............................................................

99

Aiming Adjustment Procedure ...............................

100

FRONT FOG LAMP AIMING ADJUSTMENT ..

101

Description ............................................................

101

Aiming Adjustment Procedure ...............................

101

REMOVAL AND INSTALLATION .............

103

FRONT COMBINATION LAMP ........................

103

Exploded View  ......................................................

103

Removal and Installation .......................................

104

Replacement .........................................................

104

Disassembly and Assembly  ..................................

104

Inspection After Installation (HID Control Unit)  .....

105

FRONT FOG LAMP ..........................................

106

Exploded View  ......................................................

106

Removal and Installation .......................................

106

Replacement .........................................................

106

OPTICAL SENSOR  ..........................................

108

Exploded View  ......................................................

108

Removal and Installation .......................................

108

LIGHTING & TURN SIGNAL SWITCH  ............

109

Exploded View  ......................................................

109

HAZARD SWITCH ............................................

110

Exploded View  ......................................................

110

Removal and Installation .......................................

110

HEADLAMP AIMING SWITCH  ........................

111

Exploded View  ......................................................

111

Removal and Installation .......................................

111

SIDE TURN SIGNAL LAMP  .............................

112

Exploded View  ......................................................

112

REAR COMBINATION LAMP  ..........................

113

Exploded View  ......................................................

113

Removal and Installation .......................................

113

Replacement .........................................................

114

BACK-UP LAMP  ..............................................

115

Exploded View  ......................................................

115

Removal and Installation .......................................

115

Replacement .........................................................

116

HIGH-MOUNTED STOP LAMP  ......................

117

Exploded View .......................................................

117

Removal and Installation  .......................................

117

LICENSE PLATE LAMP  .................................

118

Exploded View .......................................................

118

Removal and Installation  .......................................

118

Replacement .........................................................

118

REFLEX REFLECTOR ....................................

119

Exploded View .......................................................

119

Removal and Installation  .......................................

119

SERVICE DATA AND SPECIFICATIONS 
(SDS) ..........................................................

120

SERVICE DATA AND SPECIFICATIONS 
(SDS) ...............................................................

120

Bulb Specifications  ................................................

120

HALOGEN TYPE

PRECAUTION ............................................

121

PRECAUTIONS ...............................................

121

Precaution for Supplemental Restraint System 
(SRS) "AIR BAG" and "SEAT BELT PRE-TEN-
SIONER" ...............................................................

121

Precautions for Removing Battery Terminal ..........

121

SYSTEM DESCRIPTION  ...........................

122

COMPONENT PARTS  ....................................

122

Component Parts Location  ....................................

122

Optical Sensor  .......................................................

123

Daytime Running Light Relay  ................................

123

Hazard Switch  .......................................................

123

Bulb Specifications  ................................................

123

SYSTEM ..........................................................

124

HEADLAMP SYSTEM  .............................................

124

HEADLAMP SYSTEM : System Description  .........

124

HEADLAMP SYSTEM : Circuit Diagram  ...............

125

HEADLAMP SYSTEM : Fail-safe  ..........................

125

AUTO LIGHT SYSTEM (EXCEPT FOR CANADA) ..

126

AUTO LIGHT SYSTEM (EXCEPT FOR CANADA) 
: System Description ..............................................

126

AUTO LIGHT SYSTEM (EXCEPT FOR CANADA) 
: Circuit Diagram ....................................................

128

AUTO LIGHT SYSTEM (FOR CANADA)  ................

128

AUTO LIGHT SYSTEM (FOR CANADA) : System 
Description .............................................................

129

AUTO LIGHT SYSTEM (FOR CANADA) : Circuit 
Diagram .................................................................

131

DAYTIME RUNNING LIGHT SYSTEM  ....................

131

DAYTIME RUNNING LIGHT SYSTEM : System 
Description .............................................................

132

DAYTIME RUNNING LIGHT SYSTEM : Circuit Di-
agram ....................................................................

133