Mitsubishi Lancer Evolution X. Manual - part 120

CRUISE CONTROL

TSB Revision

ENGINE AND EMISSION CONTROL

17-67

CRUISE CONTROL SYSTEM COMPONENT 
CHECK

M1172001701546

CRUISE CONTROL SWITCH CHECK

1. Remove the cruise control switch (Refer to 

P.17-68

.)

2. Measure the resistance between terminal number 2 and 

terminal number 3 when each of the "ON/OFF", "CANCEL", 
"COAST/SET" and "ACC/RES" switches is pressed. If the 
values measured at the time each switch is pressed 
correspond to those in the table below, the resistance values 
are correct.

3. Check that the cruise control switch illuminates when a 

positive battery terminal is connected to the connector 
terminal number 4, and terminal number 1 is grounded.

STOPLIGHT SWITCH CHECK

Refer to GROUP 35A, Brake Pedal, Inspection − Stoplight 

Switch Check 

P.35A-25

.

CLUTCH SWITCH CHECK <M/T>

Refer to GROUP 21A, Clutch Pedal and Master Cylinder, 
Inspection − Clutch Switch Check and Adjustment 

P.21A-7

.

THROTTLE ACTUATOR CONTROL MOTOR 
CHECK

Refer to GROUP 13A, On-vehicle Service − Throttle Actuator 

Control Motor Check 

P.13A-879

.

Terminal 
connector 
of tester

Switch 
position

Specified 
condition

2 − 3

All switches are 
released.

Open circuit

"ON/OFF" 
switch is 
pressed

Continuity (less 
than 2 ohms)

"CANCEL" 
switch is 
pressed

202.5 - 208 Ω

"COAST/SET" 
switch is 
pressed

610.5 - 624.5 Ω

"ACC/RES" 
switch is 
pressed

1838 - 1877 Ω

AC709075

2

1

3

4

1 2 3 4

AB

Cruise control switch

EMISSION CONTROL <MFI - T/C>

TSB Revision

ENGINE AND EMISSION CONTROL

17-68

CRUISE CONTROL SWITCH

REMOVAL AND INSTALLATION

M1172007600395

Since the cruise control switch is mounted on the 
spoke of the steering wheel garnish, refer to Steering 
Wheel for removal and installation (Refer to GROUP 
37, Steering Wheel 

P.37-29

.)

EMISSION CONTROL <MFI - T/C>

GENERAL INFORMATION

M1173000101243

The emission control system consists of the fol-

lowing subsystems:

• Positive crankcase ventilation (PCV) system

• Evaporative emission system
• Exhaust emission control system

SERVICE SPECIFICATIONS

M1173000301098

DIAGNOSIS

M1173000700231

SPECIAL TOOL

M1173000601022

Item

Standard value

Emission control system
Evaporative emission purge solenoid coil resistance [at 20° C (68° F)] Ω

22 − 26

Evaporative emission ventilation solenoid coil resistance [at 20° C (68° F)] Ω

17 − 21

Purge flow cm

3

/s (SCFH) [at 80 − 95° C (176 − 205° F) with sudden revving]

20 (2.5)

SYMPTOM

PROBABLE CAUSE

REMEDY

Engine will not start or hard 
to start

Vacuum hose disconnected or damaged

Repair or replace

Malfunction of the evaporative emission 
purge solenoid

Repair or replace

Rough idle or engine stalls

Vacuum hose disconnected or damaged.

Repair or replace

Malfunction of the PCV valve

Replace

Malfunction of the purge control system

Check the system; If there is a 
problem, check its component 
parts.

Excessive oil consumption

PCV line clogged

Check PCV system

Tool

Tool number and name

Supersession

Application

MB995061
Purge flow indicator

MLR6890A
Part of MIT280220

Inspection of purge control 
system

EMISSION CONTROL <MFI - T/C>

TSB Revision

ENGINE AND EMISSION CONTROL

17-69

VACUUM HOSES

VACUUM HOSE ROUTING

M1173000901841

AK900298

B

B

B

B

B

R

B

W

B

R

Y

W

B

B

B

B

Intake manifold

Front

White paint
mark

B  : Black
R  : Red
W : White
Y  : Yellow

No. 1 turbocharger
wastgate solenoid

Evaporative emission
ventilation solenoid

Fuel tank

No. 2 turbocharger
wastgate solenoid

Air cleaner

Check
valve

Rocker cover

Fuel
pressure
regulator

Turbocharger

Turbochager
wastgate actuator

White paint
mark

AB

Evaporative emission
purge solenoid

Brown

Bule paint
mark

Turbocharger
bypass valve

EMISSION CONTROL <MFI - T/C>

TSB Revision

ENGINE AND EMISSION CONTROL

17-70

VACUUM CIRCUIT DIAGRAM

M1173007100995

AK900299AB

Evaporative 
emission 
purge 
solenoid
(on: open)

Check valve

Fuel pressure
regulator

Turbocharger 
bypass valve

B

B

B

B

B

B

B

B: BLACK
R: RED
W: WHITE
Y: YELLOW

Intake manifold

From
air
cleaner

To
combustion
chamber

Throttle body

Evaporative emission 
ventilation solenoid 
(ON: Close)

Evaporative emission canister

Turbochager

Turbochager
wastegate
actuator

No. 2 turbochager
wastegate solenoid

No. 1 turbochager
wastegate solenoid

Air cleaner

Fuel tank

R

B

B

B

W

W

Y

R

White
paint mark

Bule
paint mark

White
paint mark