Index Isuzu Isuzu Axiom - Electrical system manual 2003 year
|
|
|
10-1
POWER DISTRIBUTION
H-8
Connector
A
FUSE/RELAY BOX
BLK/YEL
DASH
FUSE
BOX
2
1
E-34
Connector
METER
ASSEMBLY
Pages 33
and 81-1
IGNITION
SWITCH
EB-17
IGN. B1
60A
WHT/BLK
EB-13
PCM
BACKUP
10A
I-32
7
WHT/BLK
WHT/BLK
H-11
Connector
7
WHT
RED/WHT
20
POWERTRAIN
CONTROL
MODULE (PCM)
Pages 24
and 39
3
WHT/BLK
To D
on
this
page.
WHT
BLK/RED
5
BLK/YEL
BLK/RED
BLK/RED
BLK/
RED
BLK/
RED
I-32
WHT/BLK
START
ON
ACC
OFF
LOCK
START
ON
ACC
OFF
LOCK
START
ON
ACC
OFF
LOCK
BLU
C-11
METER
15A
C-17
FT
WIPER
20A
C-15
ELEC.
IG.
15A
C-20
ANTI-
THEFT
10A
See Dash
Fuse Box,
page 11-5.
C-22
SRS
10A
C-14
BACK UP/
TURN
15A
See Dash
Fuse Box,
page 11-1.
C-12
ENGINE
15A
C-13
IG.
COIL
15A
BLK/
RED
C-16
RR
WIPER
10A
WHT/BLU
4
BLK/WHT
START
ON
ACC
OFF
LOCK
See Dash
Fuse Box,
page 11-4.
C-3
STARTER
10A
See Dash
Fuse Box,
page 11-6.
See Dash
Fuse Box,
page 11-2
PCM
MAIN RELAY
Pages 24, 33,
34, and 39
EB-15
PCM
30A
5
X-11
Contact
RED/WHT
H-6
Connector
9
RED/WHT
RED/WHT
RED/WHT
57
I-24
Connector
13
H-10
Connector
11
RED/WHT
B
To B on
page 10-2.
See Dash
Fuse Box,
page 11-3.
See Dash
Fuse Box,
page 11-5.
BLU
RED/WHT
RED/WHT
D
From A on
page 10.
BLK/YEL
To C on
this page.
EB-4
SEAT
HEATER
15A
H-13
Con-
nector
7
BLK/YEL
BLK/YEL
BLK/YEL
RED/BLU
BLK/YEL
RIGHT FRONT
SEAT HEATER
SWITCH
Page 147-1
B-11
Con-
nector
3
3
RED/BLU
RED/BLU
5
X-12
FUEL
PUMP
RELAY
Page 24-1
Contact
WHT/BLK
DRIVER’S
SEAT
HEATER
SWITCH
Page 147
B-12
Con-
nector
3
RED/BLU
See Dash
Fuse Box,
page 11-3.
C-23
IMMOBI-
LIZER
10A
WHT/BLK
WHT/BLK
WHT/BLK
C
From C on
this page.
I-32
From D on
this page.
D
C
Circuit Schematic
10-2
POWER DISTRIBUTION
FUSE/
RELAY
BOX
RED
RED
RED
5
X-3
RH HEADLAMP
RELAY
Pages 100
and 133-8
Contact
Coil
EB-2
HORN
10A
GRN
2
I-14
Connector
HAZARD
WARNING
SWITCH
Pages 110-5
and 118-1
EB-1
HAZARD
15A
H-14
Connector
13
WHT
16
DATA LINK
CONNECTOR
(DLC)
Pages 24-1
and
38
ALARM
and RELAY
CONTROL
UNIT
Pages 40, 70
and 73.
GRN/WHT
1
ANTI-THEFT
HORN
Page 133-1
C-3
Connector
GRN
H-14
Connector
2
2
GENERATOR
Page 22
H-2
Connector
1
GRN/YEL
J/C B
From B on
page 10-1.
B
OPTION
BOX
PNK
11
PNK
PNK
24
C-46
Connector
INTELLIGENT
SUSPENSION
CONTROL
UNIT
Page 38
BLU/BLK
EB-3
ACG (S)
10A
GRN/YEL
P-7
Connector
RED/BLK
RED/BLK
RED/
BLK
5
X-9
LH HEADLAMP
RELAY
Pages 100
and 133-8
Contact
Coil
1
EB-21
SEMI. ACT.
SUS
(ACTIVE RIDE)
30A
C-39
Connector
2
I-41
Connector
12
GRN/WHT
GRN/WHT
GRN/WHT
GRN/WHT
Circuit Schematic
10-3
POWER DISTRIBUTION
(Refer to Section 201 for photographs.)
Component
Photo No.
Alarm and Relay Control Unit
Right side of I/P
60
. . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti-theft Horn
Right rear of engine compartment
9
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Condenser Fan Relay
Right rear of engine compartment
10
. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dash Fuse Box
Behind left I/P side trim panel
42
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Data Link Connector (DLC)
C-39
(16-BLK)
Below left side of I/P, near engine hood release
45
. . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
Electronic Hydraulic Control
Unit (EHCU)
Right rear corner of engine compartment
16
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fog Lamp Relay
In the fuse & relay box
. . . . . . . . . . . . . .
Fuel Pump Relay
In the fuse & relay box
13
. . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse/Relay Box
Right side of engine compartment
8
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Generator
Lower right front of engine
35
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heater-A/C Relay
In the fuse & relay box
13
. . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition Switch
On the steering column
. . . . . . . . . . . . . . . .
Intelligent Suspension
Control unit
Below center of I/P
68
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Junction Connector A
In the fuse & relay box
14
. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Junction Connector B
In the fuse & relay box
14
. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
LH Headlamp Relay
In the fuse & relay box
11
. . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Meter Assembly
Left side of I/P
55
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Option Box
Right side of the engine compartment
8
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PCM Main Relay
In the fuse & relay box
12
. . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Powertrain Control Module
(PCM)
Left side of engine compartment
26
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Defogger Relay
In the dash fuse box
43
. . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
RH Headlamp Relay
In the fuse & relay box
12
. . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starter
Bottom left side of engine
37
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starter Relay
In the fuse & relay box
11
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
T.O.D. Control Unit
Below left side of I/P
51
. . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connector
C-3
(2-BLK)
Right rear of engine compartment
9
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
H-2 (2-GRY)
Right rear of engine compartment
10
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
H-4 (52-GRY)
Left side of engine compartment
31
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
H-6 (16-BLK)
Left side of engine compartment
31
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
H-8 (12-BLU)
Right side of engine compartment
31
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
H-10
(22-BLK)
Behind left kick panel
46
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
H-13 (19-WHT)
Behind right kick panel
62
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
H-14
(19-BLK)
Behind right kick panel
62
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
H-17 (12-WHT)
Behind right kick panel
61
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
I-24 (30-GRN)
Top of meter assembly
54
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
I-32 (8-WHT)
Under left side of I/P
48
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
P-1
Positive battery terminal
. . . . . . . . . . . . . . . . . . . . . . . . . .
P-2
In the fuse & relay box
14
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
P-3
In the fuse & relay box
14
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
P-4
Bottom left side of engine
37
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
P-6
Lower right front of engine
35
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
P-7 (2-BLK)
Lower right front of engine
35
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
P-8
Negative battery terminal
. . . . . . . . . . . . . . . . . . . . . . . . . .
Ground
P-9
Right side of engine compartment
15
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
P-10
Right side of engine compartment
15
. . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Component Location Index
DASH FUSE BOX
Accessory Socket Relay
Alarm and Relay Control Unit
Audio and Switch Assembly
Auto A/C Control Unit
Automatic Transmission Mode Switch
Brake Switch
Condenser
Dash Fuse Box
Electronic Hydraulic Control Unit (EHCU)
Evaporative Emissions (EVAP) Canister Cut Valve
Evaporative Emissions (EVAP) Canister Purge Valve
Fuse/Relay Box
GPS Receiver Unit
Heater-A/C Relay
Immobilizer Control Unit
Intelligent Suspension Control Unit
Ion Sensing Module
Keyless Entry and Anti-Theft Control Unit
Mass Air Flow (MAF) Sensor
Meter Assembly
MID Control Unit
MID Display
Multi-plexed Indicator Control Unit
No. 1 Ignition Coil
No. 2 Ignition Coil
No. 3 Ignition Coil
No. 4 Ignition Coil
No. 5 Ignition Coil
No. 6 Ignition Coil
PCM Main Relay
Power Window Relay
Powertrain Control Module (PCM)
Rear Defogger Relay
Rear Wiper Motor
Sensing and Diagnostic Module (SDM)
Shift Lock Relay
Shift-On-The-Fly Controller
T.O.D. Control Unit
Taillamp Relay
Variable Intake Manifold Vacuum Switching Valve
Windshield Wiper Motor
Component Index
|
|
|