Hyundai Santa Fe XL (2019 year). Instruction - part 27
Maintenance
NORMAL MAINTENANCE SCHEDULE
The following maintenance services must be performed to ensure good emission control and performance.
Keep receipts for all vehicle emission services to protect your warranty. Where both mileage and time are shown, the
frequency of service is determined by whichever occurs first.
*1 : If TOP TIER Detergent Gasoline is not available, one
*3 : Transfer case oil and rear axle oil should be changed
bottle of additive is recommended. Additives are avail-
anytime they have been submerged in water.
able from your authorized HYUNDAI dealer along with
*4 : Inspect for excessive tappet noise and/or engine
information on how to use them. Do not mix other
vibration and adjust if necessary.
additives.
*5 : The drive belt should be replaced when cracks occur
*2 : Fuel filter & Fuel tank air filter are considered to be
or tension is reduced excessively.
maintenance free but periodic inspection is recom-
mended for this maintenance schedule depends on
fuel quality. If there are some important safety matters
like fuel flow restriction, surging, loss of power, hard
starting problem etc, replace the fuel filter immediate-
ly regardless of maintenance schedule and consult an
authorized HYUNDAI dealer for details.
7 9
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
7,500 miles (12,000 km) or 6 months
15,000 miles (24,000 km) or 12 months
❑ Rotate tire
❑ Rotate tire
❑ Inspect battery condition
❑ Inspect battery condition
❑ Inspect air cleaner filter
❑ Inspect air cleaner filter
❑ Inspect vacuum hose
❑ Inspect vacuum hose
❑ Replace engine oil and filter
❑ Inspect air conditioning refrigerant
(7,500 miles (12,000 km) or 12 months)
❑ Inspect brake hoses and lines
❑ Add fuel additive *1
❑ Inspect drive shafts and boots
(7,500 miles (12,000 km) or 12 months)
❑ Inspect exhaust pipe and muffler
❑ Inspect front brake disc/pads, calipers
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
❑ Inspect propeller shaft (AWD)
replace.
❑ Inspect rear brake disc/pads
❑ Inspect steering gear box, linkage & boots/lower arm ball
joint, upper arm ball joint
❑ Inspect suspension mounting bolts
❑ Replace climate control air filter
(for evaporator and blower unit)
❑ Replace engine oil and filter
(15,000 miles (24,000 km) or 24 months)
❑ Add fuel additive *1
(15,000 miles (24,000 km) or 24 months)
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
replace.
7 10
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
22,500 miles (36,000 km) or 18 months
30,000 miles (48,000 km) or 24 months
❑ Rotate tire
❑ Rotate tire
❑ Inspect battery condition
❑ Inspect battery condition
❑ Inspect air cleaner filter
❑ Inspect vacuum hose
❑ Inspect vacuum hose
❑ Inspect air conditioning refrigerant
❑ Replace engine oil and filter
❑ Inspect brake hoses and lines
(22,500 miles (36,000 km) or 36 months)
❑ Inspect drive shafts and boots
❑ Add fuel additive *1
❑ Inspect exhaust pipe and muffler
(22,500 miles (36,000 km) or 36 months)
❑ Inspect front brake disc/pads, calipers
❑ Inspect propeller shaft (AWD)
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
❑ Inspect rear brake disc/pads
replace.
❑ Inspect steering gear box, linkage & boots/lower arm ball
joint, upper arm ball joint
❑ Inspect suspension mounting bolts
❑ Inspect brake fluid
❑ Inspect fuel filter *2
❑ Inspect fuel lines, fuel hoses and connections
❑ Inspect fuel tank air filter (if equipped) *2
❑ Inspect parking brake
❑ Inspect vapor hose and fuel filler cap, fuel tank
❑ Replace climate control air filter
(for evaporator and blower unit)
(Continued)
7 11
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
(Continued)
37,500 miles (60,000 km) or 30 months
❑ Replace air cleaner filter
❑ Rotate tire
❑ Replace engine oil and filter
❑ Inspect battery condition
(30,000 miles (48,000 km) or 48 months)
❑ Inspect air cleaner filter
❑ Add fuel additive *1
❑ Inspect vacuum hose
(30,000 miles (48,000 km) or 48 months)
❑ Inspect rear axle oil (AWD) *3
❑ Inspect transfer case oil (AWD) *3
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
❑ Replace engine oil and filter
replace.
(37,500 miles (60,000 km) or 60 months)
❑ Add fuel additive *1
(37,500 miles (60,000 km) or 60 months)
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
replace.
7 12
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
45,000 miles (72,000 km) or 36 months
52,500 miles (84,000 km) or 42 months
❑ Rotate tire
❑ Rotate tire
❑ Inspect battery condition
❑ Inspect battery condition
❑ Inspect air cleaner filter
❑ Inspect air cleaner filter
❑ Inspect vacuum hose
❑ Inspect vacuum hose
❑ Inspect air conditioning refrigerant
❑ Replace engine oil and filter
❑ Inspect brake hoses and lines
(52,500 miles (84,000 km) or 84 months)
❑ Inspect drive shafts and boots
❑ Add fuel additive *1
❑ Inspect exhaust pipe and muffler
(52,500 miles (84,000 km) or 84 months)
❑ Inspect front brake disc/pads, calipers
❑ Inspect propeller shaft (AWD)
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
replace.
❑ Inspect rear brake disc/pads
❑ Inspect steering gear box, linkage & boots/lower arm ball
joint, upper arm ball joint
❑ Inspect suspension mounting bolts
❑ Replace climate control air filter
(for evaporator and blower unit)
❑ Replace engine oil and filter
(45,000 miles (72,000 km) or 72 months)
❑ Add fuel additive *1
(45,000 miles (72,000 km) or 72 months)
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
replace.
7 13
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
60,000 miles (96,000 km) or 48 months
(Continued)
❑ Rotate tire
❑ Inspect drive belts
❑ Inspect battery condition
(First, 60,000 miles (96,000 km) or 72 months
❑ Inspect vacuum hose
after that, every 15,000 miles (24,000 km) or 24 months) *5
❑ Inspect air conditioning refrigerant
❑ Replace climate control air filter
❑ Inspect brake hoses and lines
(for evaporator and blower unit)
❑ Inspect drive shafts and boots
❑ Replace air cleaner filter
❑ Inspect exhaust pipe and muffler
❑ Replace engine oil and filter
❑ Inspect front brake disc/pads, calipers
(60,000 miles (96,000 km) or 96 months)
❑ Inspect propeller shaft (AWD)
❑ Add fuel additive *1
❑ Inspect rear brake disc/pads
(60,000 miles (96,000 km) or 96 months)
❑ Inspect steering gear box, linkage & boots/lower arm ball
joint, upper arm ball joint
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
❑ Inspect suspension mounting bolts
replace.
❑ Inspect brake fluid
❑ Inspect fuel filter *2
❑ Inspect fuel lines, fuel hoses and connections
❑ Inspect fuel tank air filter (if equipped) *2
❑ Inspect parking brake
❑ Inspect vapor hose and fuel filler cap, fuel tank
❑ Inspect valve clearance *4
(60,000 miles (96,000 km) or 72 months)
(Continued)
7 14
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
67,500 miles (108,000 km) or 54 months
75,000 miles (120,000 km) or 60 months
❑ Rotate tire
❑ Rotate tire
❑ Inspect battery condition
❑ Inspect battery condition
❑ Inspect air cleaner filter
❑ Inspect air cleaner filter
❑ Inspect vacuum hose
❑ Inspect vacuum hose
❑ Replace engine oil and filter
❑ Inspect air conditioning refrigerant
(67,500 miles (108,000 km) or 108 months)
❑ Inspect brake hoses and lines
❑ Add fuel additive *1
❑ Inspect drive shafts and boots
(67,500 miles (108,000 km) or 108 months)
❑ Inspect exhaust pipe and muffler
❑ Inspect front brake disc/pads, calipers
❑ Inspect propeller shaft (AWD)
❑ Inspect rear brake disc/pads
❑ Inspect steering gear box, linkage & boots/lower arm ball
joint, upper arm ball joint
❑ Inspect suspension mounting bolts
❑ Inspect rear axle oil (AWD) *3
❑ Inspect transfer case oil (AWD) *3
❑ Inspect drive belts
(First, 60,000 miles (96,000 km) or 72 months
5
after that, every 15,000 miles (24,000 km) or 24 months)*
❑ Replace climate control air filter
(for evaporator and blower unit)
(Continued)
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
replace.
7
15
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
(Continued)
82,500 miles (132,000 km) or 66 months
❑ Replace engine oil and filter
❑ Rotate tire
(75,000 miles (120,000 km) or 120 months)
❑ Inspect battery condition
❑ Replace coolant
❑ Inspect air cleaner filter
(First, 120,000 miles (192,000 km) or 60 months
❑ Inspect vacuum hose
after every 30,000 miles (48,000 km) or 24 months)
❑ Replace engine oil and filter
❑ Add fuel additive *1
(82,500 miles (132,000 km) or 132 months)
(75,000 miles (120,000 km) or 120 months)
❑ Add fuel additive *1
(82,500 miles (132,000 km) or 132 months)
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
replace.
7 16
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
90,000 miles (144,000 km) or 72 months
(Continued)
❑ Replace climate control air filter
❑ Rotate tire
(for evaporator and blower unit)
❑ Inspect battery condition
❑ Replace air cleaner filter
❑ Inspect vacuum hose
❑ Replace engine oil and filter
❑ Inspect air conditioning refrigerant
(90,000 miles (144,000 km) or 144 months)
❑ Inspect brake hoses and lines
❑ Add fuel additive *1
❑ Inspect drive shafts and boots
(90,000 miles (144,000 km) or 144 months)
❑ Inspect exhaust pipe and muffler
❑ Inspect front brake disc/pads, calipers
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
❑ Inspect propeller shaft (AWD)
replace.
❑ Inspect rear brake disc/pads
❑ Inspect steering gear box, linkage & boots/lower arm ball
joint, upper arm ball joint
❑ Inspect suspension mounting bolts
❑ Inspect brake fluid
❑ Inspect fuel filter *2
❑ Inspect fuel lines, fuel hoses and connections
❑ Inspect fuel tank air filter (if equipped) *2
❑ Inspect parking brake
❑ Inspect vapor hose and fuel filler cap, fuel tank
❑ Inspect drive belts
(First, 60,000 miles (96,000 km) or 72 months
5
after that, every 15,000 miles (24,000 km) or 24 months) *
(Continued)
7 17
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
97,500 miles (156,000 km) or 78 months
105,000 miles (168,000 km) or 84 months
❑ Rotate tire
❑ Rotate tire
❑ Inspect battery condition
❑ Inspect battery condition
❑ Inspect air cleaner filter
❑ Inspect air cleaner filter
❑ Inspect vacuum hose
❑ Inspect vacuum hose
❑ Inspect air conditioning refrigerant
❑ Replace engine oil and filter
❑ Inspect brake hoses and lines
(97,500 miles (156,000 km) or 156 months)
❑ Inspect drive shafts and boots
❑ Replace spark plugs
❑ Inspect exhaust pipe and muffler
(Every 100,000 miles (160,000 km) or 10 years)
❑ Add fuel additive *1
❑ Inspect front brake disc/pads, calipers
❑ Inspect propeller shaft (AWD)
(97,500 miles (156,000 km) or 156 months)
❑ Inspect rear brake disc/pads
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
❑ Inspect steering gear box, linkage & boots/lower arm ball
replace.
joint, upper arm ball joint
❑ Inspect suspension mounting bolts
❑ Inspect drive belts
(First, 60,000 miles (96,000 km) or 72 months
5
after that, every 15,000 miles (24,000 km) or 24 months) *
❑ Replace climate control air filter
(for evaporator and blower unit)
❑ Replace engine oil and filter
(105,000 miles (168,000 km) or 168 months)
(Continued)
7 18
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
(Continued)
112,500 miles (180,000 km) or 90 months
❑ Replace coolant
❑ Rotate tire
(First, 120,000 miles (192,000 km) or 60 months
❑ Inspect battery condition
after every 30,000 miles (48,000 km) or 24 months)
❑ Inspect air cleaner filter
❑ Add fuel additive *1
❑ Inspect vacuum hose
(105,000 miles (168,000 km) or 168 months)
❑ Inspect rear axle oil (AWD) *3
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
❑ Inspect transfer case oil (AWD) *3
replace.
❑ Replace engine oil and filter
(112,500 miles (180,000 km) or 180 months)
❑ Add fuel additive *1
(112,500 miles (180,000 km) or 180 months)
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
replace.
7 19
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
120,000 miles (192,000 km) or 96 months
(Continued)
❑ Rotate tire
❑ Inspect drive belts
❑ Inspect battery condition
(First, 60,000 miles (96,000 km) or 72 months
❑ Inspect vacuum hose
after that, every 15,000 miles (24,000 km) or 24 months) *5
❑ Inspect air conditioning refrigerant
❑ Replace climate control air filter
❑ Inspect brake hoses and lines
(for evaporator and blower unit)
❑ Inspect drive shafts and boots
❑ Replace air cleaner filter
❑ Inspect exhaust pipe and muffler
❑ Replace engine oil and filter
❑ Inspect front brake disc/pads, calipers
(120,000 miles (192,000 km) or 192 months)
❑ Inspect propeller shaft (AWD)
❑ Replace coolant
❑ Inspect rear brake disc/pads
(First, 120,000 miles (192,000 km) or 60 months
❑ Inspect steering gear box, linkage & boots/lower arm ball
after that, every 30,000 miles (48,000 km) or 24 months)
joint, upper arm ball joint
❑ Add fuel additive *1
❑ Inspect suspension mounting bolts
(120,000 miles (192,000 km) or 192 months)
❑ Inspect brake fluid
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
❑ Inspect fuel filter *2
replace.
❑ Inspect fuel lines, fuel hoses and connections
❑ Inspect fuel tank air filter (if equipped) *2
❑ Inspect parking brake
❑ Inspect vapor hose and fuel filler cap, fuel tank
❑ Inspect valve clearance *4
(120,000 miles (192,000 km) or 144 months)
(Continued)
7 20
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
127,500 miles (204,000 km) or 102 months
135,000 miles (216,000 km) or 108 months
❑ Rotate tire
❑ Rotate tire
❑ Inspect battery condition
❑ Inspect battery condition
❑ Inspect air cleaner filter
❑ Inspect air cleaner filter
❑ Inspect vacuum hose
❑ Inspect vacuum hose
❑ Replace engine oil and filter
❑ Inspect air conditioning refrigerant
(127,500 miles (204,000 km) or 204 months)
❑ Inspect brake hoses and lines
❑ Add fuel additive *1
❑ Inspect drive shafts and boots
(127,500 miles (204,000 km) or 204 months)
❑ Inspect exhaust pipe and muffler
❑ Inspect front brake disc/pads, calipers
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
❑ Inspect propeller shaft (AWD)
replace.
❑ Inspect rear brake disc/pads
❑ Inspect steering gear box, linkage & boots/lower arm ball
joint, upper arm ball joint
❑ Inspect suspension mounting bolts
❑ Inspect drive belts
(First, 60,000 miles (96,000 km) or 72 months
5
after that, every 15,000 miles (24,000 km) or 24 months) *
❑ Replace climate control air filter
(for evaporator and blower unit)
❑ Replace engine oil and filter
(135,000 miles (216,000 km) or 216 months)
(Continued)
7 21
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
(Continued)
142,500 miles (228,000 km) or 114 months
❑ Rotate tire
❑ Replace coolant
❑ Inspect battery condition
(First, 120,000 miles (192,000 km) or 60 months
❑ Inspect air cleaner filter
after that, every 30,000 miles (48,000 km) or 24 months)
❑ Inspect vacuum hose
❑ Add fuel additive *1
❑ Replace engine oil and filter
(135,000 miles (216,000 km) or 216 months)
(142,500 miles (228,000 km) or 228 months)
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
❑ Add fuel additive *1
replace.
(142,500 miles (228,000 km) or 228 months)
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
replace.
7 22
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.)
150,000 miles (240,000 km) or 120 months
(Continued)
❑ Rotate tire
❑ Inspect drive belts
❑ Inspect battery condition
(First, 60,000 miles (96,000 km) or 72 months
❑ Inspect vacuum hose
after that, every 15,000 miles (24,000 km) or 24 months) *5
❑ Inspect air conditioning refrigerant
❑ Replace climate control air filter
❑ Inspect brake hoses and lines
(for evaporator and blower unit)
❑ Inspect drive shafts and boots
❑ Replace air cleaner filter
❑ Inspect exhaust pipe and muffler
❑ Replace engine oil and filter
❑ Inspect front brake disc/pads, calipers
(150,000 miles (240,000 km) or 240 months)
❑ Inspect propeller shaft (AWD)
❑ Replace coolant
❑ Inspect rear brake disc/pads
(First, 120,000 miles (192,000 km) or 60 months
❑ Inspect steering gear box, linkage & boots/lower arm ball
after every 30,000 miles (48,000 km) or 24 months)
joint, upper arm ball joint
❑ Add fuel additive *1
❑ Inspect suspension mounting bolts
(150,000 miles (240,000 km) or 240 months)
❑ Inspect brake fluid
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
❑ Inspect fuel filter *2
replace.
❑ Inspect fuel lines, fuel hoses and connections
❑ Inspect fuel tank air filter (if equipped) *2
No check, No service required
❑ Inspect parking brake
❑ Automatic transaxle fluid
❑ Inspect vapor hose and fuel filler cap, fuel tank
❑ Inspect rear axle oil (AWD) *3
❑ Inspect transfer case oil (AWD) *3
(Continued)
7 23
Maintenance
MAINTENANCE UNDER SEVERE USAGE CONDITIONS
The following items must be serviced more frequently on cars normally used under severe driving conditions. Refer
to the chart below for the appropriate maintenance intervals.
R : Replace
I : Inspect and, after inspection, clean, adjust, repair or replace if necessary
MAINTENANCE
DRIVING CONDI-
MAINTENANCE ITEM
MAINTENANCE INTERVALS
OPERATION
TION
EVERY 3,750 MILES (6,000 KM)
A, B, C, D, E, F, G,
ENGINE OIL AND FILTER
R
OR 6 MONTHS
H, I, K
AIR CLEANER FILTER
R
MORE FREQUENTLY
C, E
SPARK PLUGS
R
MORE FREQUENTLY
B, H
AUTOMATIC TRANSAXLE FLUID
R
EVERY 60,000 MILES (96,000 KM)
A, B, F, G, H, I, J, K
FRONT BRAKE DISC/PADS, CALIPERS
I
MORE FREQUENTLY
C, D, G, H
REAR BRAKE DISC /PADS
I
MORE FREQUENTLY
C, D, G, H
PARKING BRAKE
I
MORE FREQUENTLY
C, D, G, H
STEERING GEAR BOX, LINKAGE &
BOOTS/LOWER ARM BALL JOINT,
I
MORE FREQUENTLY
C, D, E, F, G, H, I
UPPER ARM BALL JOINT
7 24
Maintenance
MAINTENANCE
DRIVING CONDI-
MAINTENANCE ITEM
MAINTENANCE INTERVALS
OPERATION
TION
EVERY 7,500 MILES (12,000 KM) OR
DRIVE SHAFTS AND BOOTS
I
C, D, E, F, G, H, I, J
6 MONTHS
TRANSFER CASE OIL (AWD)
R
EVERY 75,000 MILES (120,000 KM)
C, D, E, G, H, I, J
REAR AXLE OIL (AWD)
R
EVERY 75,000 MILES (120,000 KM)
C, D, E, G, H, I, J
CLIMATE CONTROL AIR FILTER
(FOR EVAPORATOR AND BLOWER
R
MORE FREQUENTLY
C, E
UNIT)
EVERY 7,500 MILES (12,000 KM) OR
PROPELLER SHAFT
I
C, E
6 MONTHS
SEVERE DRIVING CONDITIONS
A-Repeatedly driving short distance of less than 5 miles (8 km)
F-Driving in heavy traffic area over 90°F (32°C)
in normal temperature or less than 10 miles (16 km) in freez-
G-Driving on uphill, downhill, or mountain road
ing temperature
H-Towing a Trailer, or using a camper, or roof rack
B-Extensive engine idling or low speed driving for long dis-
I
- Driving as a patrol car, taxi, other commercial use or vehicle
tances
towing
C-Driving on rough, dusty, muddy, unpaved, graveled or salt-
J-Driving over 106 mph (170 km/h)
spread roads
K-Frequently driving in stop-and-go conditions
D-Driving in areas using salt or other corrosive materials or in
very cold weather
E-Driving in sandy areas
7 25