11.5 Glasses / Windows / Mirrors

11.5.1 Specifications
11.5.1.1 Fastener Tightening Specifications

Applications

Model

Specifications

Metric (Nm)

US English (lb-ft)

Window Glass Regulator Assembly Nuts

M6

7-9

5-7

Window Glass Regulator Assembly Bolts

M6 × 10

7-9

5-7

Window Sealing Strip Self-Tapping Screws

4.2 × 9

3-4

2-3

Window Express Down Module Retaining Bolts

M6 × 16

7-9

5-7

Body Electric

Glasses / Windows / Mirrors

11-153

11.5.2 Description and Operation
11.5.2.1 Description and Operation

Window Regulator Description and Operation

Anti-trap  function  has  the  following  four  kinds  of  operating
modes:  manual-up,  manual-down,  automatic-up,  automatic-
down.  Window  regulator  without  anti-trap  function  has  two
kinds of operating modes: manual-up, manual-down. Please
review  the  configuration  instructions  before  use  and  confirm
whether the anti-trap function is available.

–

Manual - Up

Gently pull the left front door window switch (pull up and the
holding time is less than 500 ms), the left front window rises;
the rest windows operation is the same.

–

Manual - Down

Gently press the left front door window switch (press and
the holding time is less than 500 ms), left front window goes
down; the rest windows operation is the same.

–

Automatic - Up

Completely pull the left front door window switch (pull up
and  the  holding  time  is  greater  than  500  ms),  left  front
window rises to the upper limit until the switch is pressed or
pulled up again; the rest windows operation is the same.

–

Automatic - Down

Completely press the left front door window switch (press
and  the  holding  time  is  greater  than  500  ms),  left  front
windows  goes  down  to  the  lower  limit  until  the  switch  is
pressed or pulled up again; the rest windows operation is
the same.

Note

During the window rising and doing down period, if
the window switch is pulled or pressed and held for
more than 500 ms, the window will change its moving
direction; If pressing the left front door window switch
no more than 500 ms, the window will stop moving.

–

Delay Function

With the ignition switch is turned on, the window is allowed
to  move.  After  90  s  the  ignition  switch  is  turned  off,  the
controller the power will be cut off to disable the operation
of the window.

–

Anti-Trap Function (If Equipped)

The window regulator control module is equipped with an
integrated obstacle detection / anti-trap system.

The anti-trap system works in the window seal all exposed
edges and 4-200 mm within the window seals. Window anti-
trap function requirements: the window has been initialized
in the automatic-up process, any obstacle within 4mm from
the  top  should  activate  the  anti-trap  function  and  the
window movement should be reversed.

Note

–

If a certain window has not been initialized or has
lost  its  initialization,  there  is  no  automatic-up
function, at this time the anti-trap function will not
be activated.

–

The  anti-trap  function  is  only  available  during
window automatic-up process.

The  anti-trap  system  meets  the  2000/4/EC  specification.
The  anti-trap  system  window  anti-trap  force  shall  not
exceed 100 N.

–

Comfort Closing Function (If Equipped) (If Equipped With
Anti-Trap Function)

Comfort  closing  is  through  a  LIN  communication  to
automatically close the window. Once the comfort closing
instruction is received, all the windows will move upward,
until the windows reach the trip destination (the windows
fully closed position). The activation sequence and delay
requirement  is  controlled  by  software.  During  comfort
closing period, the signal from the window switch will be
ignored, and the anti-trap function is active.

–

Motor Protection (If Equipped With Anti-Trap Function)

If  the  motor  runs  continuously  for  longer  than  20  s,  the
control module shuts down and loses initialization.

–

Adaptive Learn (If Equipped With Anti-Trap Function)

The  system  has  the  ability  to  adapt  to  the  vehicle
characteristics  and  environmental  conditions  throughout
the vehicle lifetime, such as seals wear.

11-154

Glasses / Windows / Mirrors

Body Electric

–

Overheating  Protection  (If  Equipped  With  Anti-Trap
Function)

Control  module  provides  protection  against  overheating
through  a  thermal  protection  algorithms  and  activates
overheating protection during anti-trap period. The system
will complete the window reverse movement, but will ignore
any  new  window  upward  command  until  the  motor  is
completely cooled down.

When the overheating protection is enabled, windows can
still open, but the windows can not be closed.

When  the  overheating  protection  is  enabled,  the  control
module can not switch to the sleep mode, until the system
exits  the  overheating  protection,  and  the  control  module
can move the window.

Outside  Rearview  Mirror  Description  and
Operation

Exterior rearview mirror is controlled by the driver door switch.
Rearview  mirror  has  3  switches.  The  left  and  right  selector
switch selects the desired rearview mirror, the direction buttons
are used to adjust the rearview mirror position.

Exterior rearview mirrors have heating elements inside. When
the rear window demister switch is pressed, the exterior mirror
heating  element  will  also  be  working.  For  defrost  function
operation. 

Refer 

to 

the 

"Rear 

Window 

Defrost"

and

11.12.2

 

Description and Operation

.

Body Electric

Glasses / Windows / Mirrors

11-155

11.5.3 System Working Principle
11.5.3.1 Power Management

–

Window regulator control module has a power supply (15
A).

–

The left front door window regulator and the left rear door
window share a power supply (30 A).

–

The right front door window regulator and the right rear door
window share a power supply (30 A).

Note

Four window regulator switches low current controls high
current,  and  have  current  protection  function;  four
window regulator motors all have continuous output 8 s
protection function.

11.5.3.2 Functional Timing Diagram

Window Up Input

Window Down Input

Window Up

Window Down

FE11-2001b

11-156

Glasses / Windows / Mirrors

Body Electric