Ford Transit (2018 year). Manual - part 114

Other maintenance items 

1

Change rear axle fluid.

Replace accessory drive belt(s).

1

 Perform these maintenance items within 3000 miles (4800 kilometers) of the last

engine oil and filter change. Do not exceed the designated distance for the interval.

2

Replace early if indicated by per Water In Fuel warning lamp.  See Warning Lamps and

Indicators (page 90).

3

 Initial replacement at six years or 100000 miles (160000 kilometers), then every three

years or 50000 miles (80000 kilometers).

4

 After initial inspection, inspect every other oil change until replaced.

SPECIAL OPERATING
CONDITIONS SCHEDULED
MAINTENANCE

If you operate your vehicle primarily in any
of the following conditions, you need to
perform extra maintenance as indicated.
If you operate your vehicle occasionally
under any of these conditions, it is not
necessary to perform the extra
maintenance. For specific
recommendations, see your dealership
service advisor or technician.

Perform the services shown in the
following tables when specified or within
3000 miles (4800 kilometers) of the oil
change required message appearing in the
information display.
•

Example 1: The message appears at
28,750 mi (46,270 km). Perform the
30,000 mi (48,000 km) automatic
transmission fluid replacement.

•

Example 2: The message does not
appear, but the odometer reads
30,000 mi (48,000 km) (for example,
the Intelligent Oil-Life Monitor was
reset at 25,000 mi (40,000 km)).
Perform the engine air filter
replacement.

Towing a trailer or using a car-top carrier

Change engine oil and filter as indicated by the information
display and perform services listed in the Normal Scheduled
Maintenance chart.

As required

Inspect and lubricate U-joints.

Inspect frequently,
service as required

See axle maintenance items under Exceptions.

Replace spark plugs.

Every 60000 miles
(96000 km)

Extensive idling or low-speed driving for long distances, as in heavy commercial use

(such as delivery, taxi, patrol car or livery)

Change engine oil and filter as indicated by the information
display and perform services listed in the Normal Scheduled
Maintenance chart.

As required

Replace engine air filter.

Inspect frequently,
service as required

Replace spark plugs.

Every 60000 miles
(96000 km)

Operating in dusty or sandy conditions (such as unpaved or dusty roads)

Replace engine air filter.

Inspect frequently,
service as required

Inspect the wheels and related components for abnormal
noise, wear, looseness or drag.

Every 5000 miles (8000
km)

Rotate tires, inspect tires for wear and measure tread depth.

Change engine oil and filter.

*

Every 5000 miles (8000
km) or six months

*

Reset your Intelligent Oil-Life Monitor after each engine oil and filter change.

Off-road operation

Inspect steering linkage, ball joints and U-joints. Lubricate if
equipped with grease fittings.

Inspect frequently,
service as required

Replace engine air filter.

Change engine oil and filter.

*

Every 5000 miles (8000
km) or six months

Inspect the wheels and related components for abnormal
noise, wear, looseness or drag.

Rotate tires, inspect tires for wear and measure tread depth.

*

Reset your Intelligent Oil-Life Monitor after each engine oil and filter change.

Exclusive use of E85 (Flex fuel vehicles only)

If ran exclusively on E85, fill the fuel tank full with regular
unleaded fuel.

Every oil change interval

Exceptions

There are several exceptions to the Normal
Schedule:

Axle and Transfer Case Maintenance

Axle(s) and transfer case (Four-wheel
drive vehicles) fluid changes or level
checks are not required unless a leak is
suspected or the assembly has been
submerged in water. Contact an authorized
dealer for service.

California fuel filter replacement

If you register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. Ford Motor Company, however,
urges you to have all recommended
maintenance services performed at the
specified intervals and to record all vehicle
service.

Hot climate oil change intervals

Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or
locations with similar climates using an
American Petroleum Institute (API)
Certified for Gasoline Engines (Certification
mark) oil of SM or SN quality, the normal
oil change interval is 5,000 mi (8,000 km).

If the available API SM or SN oils are not
available, then the oil change interval is
3,000 mi (4,800 km).

Engine air filter replacement

The life of the engine air filter is dependent
on exposure to dusty and dirty conditions.
Vehicles operated in these conditions
require frequent inspection and
replacement of the engine air filter.

•

Single EULA:  The end user
documentation for the DEVICES and
related systems and services may
contain multiple EULAs, such as
multiple translations and/or multiple
media versions (e.g., in the user
documentation and in the software).
Even if you receive multiple EULAs, you
are licensed to use only one (1) copy of
the SOFTWARE.

•

SOFTWARE Transfer: You may
permanently transfer your rights under
this EULA only as part of a sale or
transfer of the DEVICES, provided you
retain no copies, you transfer all of the
SOFTWARE (including all component
parts, the media and printed materials,
any upgrades, and, if applicable, the
Certificate(s) of Authenticity), and the
recipient agrees to the terms of this
EULA. If the SOFTWARE is an upgrade,
any transfer must include all prior
versions of the SOFTWARE.

•

Termination: Without prejudice to any
other rights, FORD MOTOR COMPANY
may terminate this EULA if you fail to
comply with the terms and conditions
of this EULA.

•

Internet-Based Services
Components: The SOFTWARE may
contain components that enable and
facilitate the use of certain
Internet-based services. You
acknowledge and agree that FORD
MOTOR COMPANY, third party
software and service suppliers, its
affiliates and/or its designated agent
may automatically check the version
of the SOFTWARE and/or its
components that you are utilizing and
may provide upgrades or supplements
to the SOFTWARE that may be
automatically downloaded to your
DEVICES.

•

Additional Software/Services: The
SOFTWARE may permit FORD MOTOR
COMPANY, third party software and
service suppliers, its affiliates and/or
its designated agent to provide or make
available to you SOFTWARE updates,
supplements, add-on components, or
Internet-based services components
of the SOFTWARE after the date you
obtain your initial copy of the
SOFTWARE ("Supplemental
Components".) SOFTWARE updates
may cause you to incur additional
charges from your wireless service
provider. If FORD MOTOR COMPANY
or third party software and services
suppliers provide or make available to
you Supplemental Components and
no other EULA terms are provided
along with the Supplemental
Components, then the terms of this
EULA shall apply. FORD MOTOR
COMPANY, its affiliates and/or its
designated agent reserve the right to
discontinue without liability any
Internet-based services provided to
you or made available to you through
the use of the SOFTWARE.