Haima S5. Owners Manual

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Safety System

◆ Ensure that the shoulder

shoulder belt. Next, check to

completion

belt fits closely to the body.

ensure that the seat belt stretches

adjustment, ensure

that

the

While fastening the seat

over the chest and shoulder

adjuster is locked.

belt, stretch the waist portion of

tightly. In such case, the impact

the seat belt over the hip as low

force can be distributed over the

as possible. Pull up the shoulder

entire upper body.

portion of seat belt to ensure that

If the seat belt comes into

the waist portion of seat belt fits

contact with the neck or only on

closely to the body. In such case,

the arms instead of the shoulder,

the strong pelvis can bear the

appropriately adjust the height

(3.3.4)

impact force in event of vehicle

of the shoulder belt.

impact, in order to reduce the

Pull upward the adjuster to

possibility of internal body

increase the height of seat belt.

injuries.

Push down the adjuster to

When necessary, pull up

reduce the height of seat belt.

the seat belt again, in order to

eliminate any looseness in

Page 32 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Safety System

rear row seat are same with the

3.4 Fixing method of child seat

front row seats.

The rear row seat of this

Tip: For the driving safety, the

vehicle is fitted with fixing

driver shall adjust the seat belt

anchorages for child seat. At

only under the stationary state of

present, the ISO FIX compliant

the vehicle. Therefore, please

child seat can be fixed on either

pay attention to adjust before the

left or right seat of the rear row

(3.3.5)

driving.

seat. At the time of use, firstly

3.3.5

Unfastening

and

Notice: One seat belt can only

align the lower legs of the child

adjustment of 3-point seat belt

be used by one passenger and

seat with the fixing anchorages

To unfasten the seat belt,

it’s

prohibited

for

two

and insert into the fixing

push down the red button on the

passengers to share one seat belt.

anchorages at the lower portion

buckle and at the same time pull

Especially, it’s of extreme

of the seat cushion. Next, pry

out the tab. The fastening

danger to stretch the seat belt

open the trunk carpet to fix the

method and unfastening method

over the passenger embracing a

upper point of child seat.

of the 3-point seat belt for the

child within his arms.

Page 33 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Safety System

IV. Airbag System

for

protecting

the

front

passenger.

Lower anchorage

The vehicle is fitted with

point of child seat

The airbag is under ready

frontal supplemental restraint

status at all times once the

system (SRS). It's functioned to

ignition switch is at position

supplementally protect the head

“ON”.

and chest of the driver and front

Tip: The airbag is the

passenger

event

supplemental protection device

medium-level

and

serious

next to the seat belt.

frontal impact.

Upper anchorage

4.1 Composition of airbag

point of child seat

The supplemental restraint

system

system includes two airbags:

The airbag system of the

◆ Driver airbag, located on

vehicle includes the following

the steering wheel for protecting

Tip: Normally, the child

seat

four parts:

the driver.

shall only be installed on the left

◆ SRS control unit

(airbag

◆ Front passenger airbag,

or right seat of the rear row seat.

control unit)

located on the instrument panel

Page 34 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Safety System

◆ Airbag warning lamp

convert to signal, and input to

◆ Front impact sensor

the micro-processor of the SRS

◆ Airbag subassembly

control unit.

The SRS control unit is the

The SRS warning lamp is

control center of the airbag

functioned to indicate whether

system and is functioned to

the airbag system is under

receive the input signal from the

normal functioning status.

impact sensor, judge the

The airbag subassembly

At the very moment of the

necessity for deployment and

includes the airbag part and the

vehicle impact, in which the

inflation of airbag, and conduct

gun powder part.

certain impact strength is

the self-diagnosis of the system

4.1.1 Working principle of

reached, the SRS control unit

malfunction.

airbag

responds rapidly to the signal

The front impact sensor is

issued by the front impact sensor

the main control signal input

and ignites the gas generator,

device in the airbag system and

which, by utilizing the rapid

is functioned to detect the

expansion principle of hot air,

impact strength of the vehicle,

rapidly inflates the airbag within

Page 35 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Safety System

a short period after the vehicle

function only when the seat belt

◆ The warning lamp fails to

impact to form an air cushion in

is fastened. In consideration of

light up when the ignition switch

front of the driver/passenger and

the safety, the front row

is rotated to position ON.

protect the head and chest of the

passengers must fasten the seat

◆ The warning lamp lights up

driver/passenger to a certain

belt during the traveling of the

still after the engine is started.

extent.

vehicle.

◆ The warning lamp lights up

Notice: In event of serious

4.1.2 Airbag warning lamp

or occasionally flashes or goes

frontal impact accident of the

When the ignition switch is

out during the driving.

vehicle, the airbag system can

rotated to position “ON” or the

In event of above problems,

provide supplemental protection

engine is started, the SRS

please contact the sales and

for the heads and chests of the

warning lamp will light up for 3s

service shop of Haima Car

front row passengers and is an

and then go out constantly,

Co.,Ltd as soon as possible. The

important constituent part of the

which indicates that the airbag

vehicle can be used normally

passive safety system of the

system is working normally.

only after the malfunction is

vehicle.

The airbag warning lamp

resolved.

Notice: The airbag system can

will probably have the following

Tip: In event of above situation,

better exert its protection

abnormalities:

it indicates that the airbag is

Page 36 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Safety System

under abnormal state. The airbag

4.2 Passenger detection system

the seriously frontal deformation

can’t be deployed normally in

(optional)

of entire parts

(such as front

event of the frontal impact

This vehicle is fitted with

longitudinal

beam),

the

accident.

passenger detection system. If a

deceleration threshold at the

Notice: It’s really dangerous to

passenger is seated in the front

mounting place of the impact

repair or modify the airbag

passenger seat without fastening

sensor will generally exceed the

system without permission,

the seat belt, the combination

critical setting of SRS control

which will probably lead to

instrument will alert by seat belt

unit and the system will deploy

accidental

deployment

lamp and sound when the

the airbag.

functional failure of the airbag

vehicle speed is above 25km/h.

and lead to personal injuries.

4.3 Deployment conditions of

The airbag system shall be

airbag

repaired only by sales and

During the traveling, if the

service shop of Haima Car

vehicle encounters a frontal

Co.,Ltd

impact against solid wall (such

as concrete wall) at a speed of

above 25km/h, which leads to

Page 37 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Safety System

If the vehicle encounters a

exhaust a slight amount of

◆ The airbag can be used only

frontal

impact

against

smoke at the deflation of the

for one time. Once deployed, the

collapsible object

(Movable or

airbag, which will not cause

airbag must be replaced. The

deformable objects such as

personal injuries. For the

airbag must be replaced by sales

vehicle and guardrail), instead of

personnel

with

respiratory

and service shop of Haima Car

the solid wall (such as concrete

system disease or weak impact

Co.,Ltd

wall), the impact speed (vehicle

resistant skin, it will bring about

4.3.2

Conditions

for

speed) for the deployment of

certain irritation to the throat or

non-deployment of airbag

airbag will be increased.

skin temporarily. In event of

First

condition

for

4.3.1 Deployment of airbag

contamination of residues (such

non-deployment of airbag

◆ The airbag deploys at very

as gas) on the skin, flush with

The airbag system will not

high speed, which will probably

clean water as soon as possible.

deploy in event of the following

lead to scratch or impact injuries

◆ After the deployment of the

impacts during the traveling, as

of the driver/passengers.

airbag, the airbag subassembly

such impacts are not belonging

◆ The system will issue high

and its vicinity are under high

to frontal impact.

inflation

sound

the

temperature. Do not touch at

deployment of airbag and

will, or it will lead to scalding.

Page 38 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Safety System

cushioning function of the body

and generally the airbag system

will not deploy.

Similarly,

these

cases

indicate that the airbag will not

◆ Rear-end impact

other

deploy as the preset conditions

vehicle.

◆ Side slip or side impact

for frontal impact are not met,

Second condition

for

even though the impact probably

non-deployment of airbag

causes personal injuries and the

In event of the following

vehicle

encounters

frontal

impacts during the traveling,

impact.

though the head of the vehicle is

under high impact deformation

and the vehicle is seriously

◆ Lateral rollover

damaged, the impact on the

driver/passengers

will

relatively low due to the

Page 39 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Safety System

◆ The frontal middle portion

◆ The frontal upper portion of

◆ The vehicle falls into a pit

of vehicle impacts with a tree or

the vehicle impacts with or

or impacts with the edge of a pit.

pole.

underruns into the bottom of

truck compartment.

◆ The vehicle falls to the

◆ The vehicle impacts with

ground fiercely or falls down

road shoulder, step, or other

while crossing over a step.

short solid object.

◆ The head of vehicle

V. Side Airbag and Side

encounters offset frontal impact.

Curtain Airbag (Optional)

Some models

(refer to

configuration table for details)

are fitted with side airbag and

side curtain airbag

(SRS). It's

Page 40 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Safety System

functioned to supplementally

portion of roof to protect the

◆ SRS control unit

(airbag

protect the heads and chests of

driver and left rear passenger.

control unit)

passengers

event

◆ The passenger side curtain

◆ Airbag warning lamp

medium-level and serious side

airbag is located on right lower

◆ Airbag and side curtain

collision.

portion of roof to protect the

airbag subassembly

The supplemental restraint

driver and right rear passenger.

◆ Side impact sensor

system includes two side airbags

The side airbag and side

The SRS control unit is the

and two side curtain airbags:

curtain airbag are under ready

control center of the airbag

◆ The driver side airbag is

status at all times once the

system and is functioned to

located within the driver seat to

ignition switch is at position

receive the input signal from the

protect the driver.

“ON”.

impact sensor, judge the

◆ The front passenger side

5.1 Composition of side airbag

necessity for deployment and

airbag is located within front

and side curtain airbag system

inflation of airbag and side

passenger seat to protect the

The side airbag and side

curtain airbag, and conduct the

front passenger.

curtain airbag system of the

self-diagnosis of the system

◆ The driver side curtain

vehicle includes the following

malfunction.

airbag is located on left lower

four parts:

Page 41 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Safety System

The side impact sensor is

Tip: The airbag and side curtain

responds rapidly to the signal

installed on the lower end of

airbag are the supplemental

issued by the sensor and ignites

inner panel of body B-pillar. As

protection devices next to the

the gas generator, which, by

the main control signal input

seat belt.

utilizing the rapid expansion

device in the airbag system, it’s

5.1.1 Working principle of side

principle of hot air, rapidly

functioned to detect the impact

airbag and side curtain airbag

inflates the airbag within a short

strength of the vehicle, convert

period after the vehicle impact

to signal, and input to the

to form an air cushion on the

micro-processor of the SRS

side

face

the

control unit.

driver/passengers and protect the

The SRS warning lamp is

head, chest, and abdomen of the

functioned to indicate whether

driver/passenger to a certain

the airbag system is under

extent.

normal functioning status.

At the very moment of the

Notice: The airbag system can

The airbag subassembly

vehicle impact, in which the

better exert its protection

includes the airbag part and the

certain impact strength is

function only when the seat belt

gun powder part.

reached, the airbag control unit

is fastened. In consideration of

Page 42 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Safety System

the safety, the front row

barrier at an energy equivalent to

the system will deploy the

passengers must fasten the seat

or in excess of 25km/h, which

airbag.

belt during the traveling of the

leads to the seriously side

vehicle.

deformation of entire parts (such

5.2 Deployment conditions for

as pillar B), the deceleration

airbag and side curtain airbag

threshold at the mounting place

During the traveling, if the

of the impact sensor will

vehicle encounters a side

generally exceed the critical

collision against a collapsible

setting of SRS control unit and

Page 43 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Configurations and Functions

indicated with “Optional” in the

door open alarm, gear of

Chapter II Configuration

manual

automatic transmission, tire

and Function

pressure

, and cruise control.

II. Combination Instrument

I. Configuration Type

The display interfaces are

The combination instrument

The vehicle equipment is

switched over by pressing the

incorporates

the

engine

classified into standard equipment

INFO button.

tachometer, speedometer, fuel

and optional equipment.

gauge, trip computer display, and

1.1 Standard equipment

all kinds of indicator lamps and

The standard equipment refers

warning lamps.

to the basic equipment of the

The trip computer display

vehicle, which is not specifically

◆ Left turn indicator lamp

can display the fuel gauge, water

described in the manual.

temperature gauge, total mileage,

1.2 Optional equipment

trip mileage A, instantaneous

Depending on different vehicle

This

indicator

lamp

fuel consumption, remaining

models, the added or substituted

flashes synchronously when

driving mileage, speeding alarm,

equipment in the products is

Page 44 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Configurations and Functions

the left turn signal lamp is turned

This indicator lamp flashes

◆ ESC OFF indicator lamp

on.

synchronously when the marker

(optional)

◆ Front fog lamp indicator lamp

lamp is turned on.

◆ Rear fog lamp indicator

This indicator lamp lights

up when the ESC system is

lamp

This indicator lamp lights up

turned off.

synchronously when the front fog

This indicator lamp lights up

◆ Brake warning lamp

lamp is turned on.

when the rear fog lamp is turned

◆ High beam indicator lamp

on.

◆ Right turn indicator lamp

This lamp will light up in

This indicator lamp lights up

event of any of the following

when the high beam is turned on.

conditions:

◆ Marker lamp indicator lamp

This indicator lamp flashez

The parking brake lever is

synchronously when the right

pulled up or is incompletely

turn signal lamp is turned on.

released.

The service brake fluid

level is too low.

Page 45 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Configurations and Functions

The electronic brake force

malfunctioned during running of

The green indicator lamp

distribution system

(EBD) is

engine, this warning lamp lights

lights up when the start/stop

malfunctioned.

up.

intelligent function is activated.

◆ ABS system warning lamp

◆ Emission

malfunction

The yellow indicator lamp

flashes when the start/stop

warning lamp

main switch is turned off or the

This warning lamp lights up

If this lamp lights up

start/stop

function

when the ABS system is

constantly during the running of

malfunctioned

against

malfunctioned. In such case, the

the engine, it indicates that the

start/stop function though it’s

brake system of the vehicle is still

engine control system detects

activated and the engine hood

functional.

that certain emission control

is opened, the rear defroster is

system of the vehicle is probably

turned on, the brake vacuum

◆ Airbag warning lamp

malfunctioned.

pressure is insufficient, and the

This lamp lights up for several

◆ Start/stop indicator lamp

driver door is opened.

seconds and then turns off when the

◆ Engine

malfunction

(optional)

ignition switch is turned to position

indicator lamp

ON. If the airbag system is

Page 46 of 250

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Configurations and Functions

If this lamp lights up during th●

Low engine oil pressure.

This warning lamp lights

running of the engine, it indicates

● Insufficient oil in lubricating

up when the water temperature

that the engine control system

is too high and the pointer of

oil line

detects the abnormality of power

water temperature gauge is

system through diagnosis.

● Over-high lubricating oil

within alarm zone.

◆ PEPS malfunction warning

temperature

◆ Low fuel level warning

ESC status indicator

(optional)

lamp (optional)

indicator lamp

This indicator lamp lights up

The warning lamp within fuel

when the PEPS or ESCL (electronic

This indicator lamp flashes

gauge lights up when the fuel

steering

column

lock)

at a frequency of 2Hz when the

within the fuel tank is about to

malfunctioned.

ESC is working normally and

be used up. Please add fuel as

◆ Engine oil pressure warning

lights up when the ESC is

soon as possible.

malfunctioned.

◆ Seat belt warning lamp

lamp

◆ Water temperature warning

There are following causes for

indicator lamp

the light-up of this warning lamp:

Page 47 of 250

Haima S5. Owners Manual - part 3