Content .. 2 3 4 5 ..

Vauxhall Movano (2016 year). Manual - part 4

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Seats, restraints

Airbag deactivation 3 55.

Child restraints

9 Danger

Airbag label 3 51.

Risk of fatal injury for a child using

Child restraint systems

The rear seats are the most

a child restraint system together

We recommend the Vauxhall child

convenient location to fasten a child

with activated front passenger

restraint system which is tailored

restraint system.

airbag.

specifically to the vehicle.

Children should travel facing

Risk of fatal injury for an adult

When a child restraint system is being

rearwards in the vehicle as long as

person with deactivated front

used, pay attention to the following

possible. This makes sure that the

passenger airbag.

usage and installation instructions

child's backbone, which is still very

and also those supplied with the child

weak, is under less strain in the event

As long as control indicator W is not

restraint system.

of an accident.

illuminated, the airbag systems for

Child locks 3 25.

Always comply with local or national

the front passenger seat will inflate in

regulations. In some countries, the

the event of a collision.

Selecting the right system

use of child restraint systems is

If control indicator A remains

forbidden on certain seats.

Suitable are restraint systems that

illuminated together with v, this

comply with valid UN ECE

indicates a fault within the system.

9 Warning

regulations. Check local laws and

The switch position may have been

regulations for mandatory use of child

changed inadvertently with the

When using a child restraint

restraint systems.

ignition on. Turn ignition off and on

system on the front passenger

Ensure that the child restraint system

again and reset the switch position. If

seat, the airbag systems for the

to be installed is compatible with the

A and v still remain illuminated,

front passenger seat must be

vehicle type.

seek the assistance of a workshop.

deactivated; if not, the triggering of

Ensure that the mounting location of

Change status only when the vehicle

the airbags poses a risk of fatal

the child restraint system within the

is stopped with the ignition off. Status

injury to the child.

vehicle is correct, see following

remains until the next change.

This is especially the case if rear-

tables.

Control indicator W for airbag

facing child restraint systems are

deactivation 3 86.

used on the front passenger seat.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Seats, restraints

Allow children to enter and exit the

vehicle only on the side facing away

from the traffic.

When the child restraint system is not

in use, secure the seat with a seat belt

or remove it from the vehicle.

Child restraint systems could be

fastened with ISOFIX mounting

brackets, Top-tether if available, and/

or a three-point seat belt. Refer to the

following tables.

Notice

Do not affix anything on the child

restraint systems and do not cover

them with any other materials.

A child restraint system which has

been subjected to stress in an

accident must be replaced.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Seats, restraints

Child restraint installation locations

Permissible options for fitting a child restraint system

Front seats - All variants

Weight and age class

Single seat - front passenger side¹⁾

Bench seat - front passenger side

without airbag

with airbag

without airbag

with airbag

centre

outer

centre

outer

Group 0: up to 10 kg

or approx. 10 months

U²⁾

Group 0+: up to 13 kg

or approx. 2 years

Group I: 9 to 18 kg

U²⁾

or approx. 8 months to 4 years

Group II: 15 to 25 kg

or approx. 3 to 7 years

U²⁾

Group III: 22 to 36 kg

or approx. 6 to 12 years

If adjustable, ensure seat is in its rearmost position. Make sure vehicle seat belt is as straight as possible between shoulder and

upper anchorage point.

Ensure the front passenger airbag system is deactivated when installing a child restraint in this position.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Seats, restraints

Doublecab - rear seats

Weight and age class

2nd row seats

Outer

Centre

Group 0: up to 10 kg

or approx. 10 months

Group 0+: up to 13 kg

or approx. 2 years

Group I: 9 to 18 kg

or approx. 8 months to 4 years

Group II: 15 to 25 kg

or approx. 3 to 7 years

Group III: 22 to 36 kg

or approx. 6 to 12 years

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Seats, restraints

Combi - rear seats

Weight and age class

2nd row seats

3rd row seats

Driver side

Passenger side

outer seat

Centre seat

outer seat

Group 0: up to 10 kg

or approx. 10 months

U³⁾, <

Group 0+: up to 13 kg

or approx. 2 years

Group I: 9 to 18 kg

U⁴⁾, <

UF⁴⁾, <

UF⁴⁾

or approx. 8 months to 4 years

Group II: 15 to 25 kg

or approx. 3 to 7 years

U⁴⁾

UF⁴⁾

Group III: 22 to 36 kg

or approx. 6 to 12 years

Move the front seat as far forward as possible to install a rear facing child seat, then move back the seat in front in accordance with

the child seat instructions.

Forward facing child seat; position the seatback of the child seat in contact with the seatback of the vehicle seat. Adjust the height

of the headrest or remove it if necessary; do not push the seat in front of the child more than halfway back on its runners and do not

recline the seatback more than 25°.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Seats, restraints

Bus - rear seats

Weight and age class

Rear seats

Group 0: up to 10 kg

or approx. 10 months

Group 0+: up to 13 kg

or approx. 2 years

Group I: 9 to 18 kg

or approx. 8 months to 4 years

Group II: 15 to 25 kg

or approx. 3 to 7 years

Group III: 22 to 36 kg

or approx. 6 to 12 years

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Seats, restraints

Crew cab - rear seats

Weight and age class

2nd row seats

Outer

Centre

Group 0: up to 10 kg

or approx. 10 months

Group 0+: up to 13 kg

or approx. 2 years

Group I: 9 to 18 kg

or approx. 8 months to 4 years

Group II: 15 to 25 kg

or approx. 3 to 7 years

Group III: 22 to 36 kg

or approx. 6 to 12 years

: suitable for universal category restraint systems for use in this weight and age class, in conjunction with three-point

seat belt.

UF : suitable for universal category forward-facing restraint systems for use in this weight and age class, in conjunction

with three-point seat belt.

< : suitable for ISOFIX child restraint system with mounting brackets and anchorage points, where fitted. When mounting

an ISOFIX child restraint system, only systems that have been approved for the vehicle may be used. Refer to

"Permissible options for fitting an ISOFIX child restraint system".

: seat position not suitable for children in this weight and age class.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Seats, restraints

Permissible options for fitting an ISOFIX child restraint system

Combi

Weight class

Size class Fixture Front seats 2nd row seats

3rd row

seats

Driver side

Passenger side

outer seat Centre seat outer seat

Group 0: up to 10 kg

ISO/R1

or approx. 10 months

Group 0+: up to 13 kg

ISO/R1

or approx. 2 years

ISO/R2

ISO/R3

Group I: 9 to 18 kg

ISO/R2

or approx. 8 months to 4 years

ISO/R3

ISO/F2

IL, IUF

ISO/F2X X

IL, IUF

ISO/F3

IL, IUF

: suitable for particular ISOFIX restraint systems of the "specific-vehicle", "restricted" or "semi-universal" categories.

The ISOFIX restraint system must be approved for the specific vehicle type.

IUF : suitable for ISOFIX forward-facing child restraint systems of universal category approved for use in this weight class.

: no ISOFIX child restraint system approved in this weight class.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Seats, restraints

ISOFIX size class and seat device

A - ISO/F3

: forward-facing child restraint system for children of maximum size in the weight class 9 to 18 kg.

B - ISO/F2

: forward-facing child restraint system for smaller children in the weight class 9 to 18 kg.

B1 - ISO/F2X

: forward-facing child restraint system for smaller children in the weight class 9 to 18 kg.

C - ISO/R3

: rear-facing child restraint system for children of maximum size in the weight class up to 18 kg.

D - ISO/R2

: rear-facing child restraint system for smaller children in the weight class up to 18 kg.

E - ISO/R1

: rear-facing child restraint system for young children in the weight class up to 13 kg.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Seats, restraints

ISOFIX child restraint

Top-tether fastening eyes

systems

Top-Tether fastening eyes are

located on the back of the seat.

Fasten vehicle-approved ISOFIX

child restraint systems to the ISOFIX

In addition to the ISOFIX mounting,

mounting brackets.

fasten the Top-Tether strap to the

Top-Tether fastening eyes.The strap

When using ISOFIX mounting

must run between the two guide rods

brackets for seat mounting,

of the head restraint.

universally approved child restraint

systems for ISOFIX may be used.

ISOFIX child restraint systems of

universal category positions are

Permissible mounting location

marked in the table by IUF.

positions for ISOFIX child restraint

systems are marked in the tables by

<, IL and IUF.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Storage

Storage compartments, pockets and

Storage

Storage compartments

trays are located in the instrument

panel.

9 Warning

A phone holder and/or a coin holder

Storage compartments

with a clip for holding tickets is located

Instrument panel storage

Do not store heavy or sharp

on the top of the instrument panel.

Glovebox

objects in the storage

The tray located centrally on top of the

Cupholders

compartments. Otherwise vehicle

instrument panel has a lid.

Front storage

occupants could be injured by

Overhead console

objects being thrown around in the

Document holder

Underseat storage

event of hard braking, a sudden

Overcab storage

change in direction or an accident.

Load compartment

Lashing eyes

Instrument panel storage

Cargo management system

Safety net

Warning triangle

First aid kit

Fire extinguisher

Roof rack system

Roof rack

Loading information

Withdraw the document holder from

the instrument panel by pulling the

base towards you and then swivelling

it downwards.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Storage

To fold away, raise the base until the

Front storage

Overhead console

document holder is horizontal, then

Three coat hooks are located on the

push fully in.

cabin bulkhead

The front door pockets contain bottle

Glovebox

holders.

Folding passenger seatback

The total weight in these

compartments must not exceed 5 kg.

The glovebox should be closed whilst

driving.

Glovebox cooler 3 116.

The passenger seat backrest, when

folded fully forwards, features storage

compartments and cupholders.

Cupholders

The swivelling shelf, which can be

Cupholders are located at either end

used for writing or documents, must

of the instrument panel and centrally

be returned to its original position

in the lower instrument panel.

before raising the seat backrest.

The cupholders can also be used to

hold the portable ashtray unit 3 79.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Storage

Underseat storage

Rear bench seat

Overcab storage

Raise seat base to gain access to

Using the two loops on the passenger

The total weight in this compartment

storage compartment under the

seat cushion, pull the cushion

must not exceed 35 kg.

bench seat.

forwards to gain access to the storage

under the seat.

Rear storage

Combi, Bus

Objects can be stored in the overhead

storage compartments above the rear

passenger seats.

The total weight must not exceed

20 kg evenly distributed.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Storage

Removable lashing eyes

Load compartment

Lashing eyes

To move, pull down on the latch to

release and position the wall as

To reposition, press down on the

required. Ensure the latch engages

centre cap and slide to the desired

fully and the partition wall is upright.

position. Ensure the lashing eye

Lashing eyes are mounted in the load

engages correctly in the recess.

compartment to enable cargo to be

secured in position using lashing

Loading information 3 72.

straps or a luggage floor net.

The maximum force applied to the

Cargo management system

lashing eyes should not exceed

6250 N at 30°.

Moveable partition wall

The moveable partition wall can be

used between the floor and roof rails.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Storage

Store the partition wall to one side of

Ratchet straps

the load compartment when not in

Using the appropriate ratchet straps,

use.

objects can be secured to the

Telescopic blocking bars

removable lashing eyes in the side or

floor load rails.

The maximum loading for the side

rails is 100 daN/700 mm.

Removable lashing eyes 3 69,

Loading information 3 72.

The telescope blocking bars can be

used in a vertical or horizontal

The maximum loading for the floor

position.

rails is 500 daN/700 mm.

Ensure the blocking bars are fully

engaged in the load rails before

To release, press down on the lock

and slide the bar at the same time.

Maximum loading 100 daN/700 mm.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Storage

Safety net

First aid kit

Fire extinguisher

As a visible indication of the presence

of a first aid kit, a label may be located

of a fire extinguisher, a label may be

on the overhead console 3 67.

located on the overhead console

3 67.

The first aid kit can be accommodated

in the space under the front seats.

The fire extinguisher can be

accommodated in the space under

the front seats. Using the two loops on

the seat cushion, pull the cushion

forwards to gain access.

Underseat storage 3 68.

Depending on version, the fire

extinguisher may alternatively be

Lower the safety net from the roof

located in the space between the front

area and attach to the lashing eyes

seats.

3 69.

Adjust the tension on the straps to

ensure the load is secure.

When not in use the safety net should

Using the two loops on the seat

be stored in the roof area.

cushion, pull the cushion forwards to

gain access.

Loading information 3 72.

Underseat storage 3 68.

Warning triangle

Depending on version, the first aid kit

may alternatively be located in the

The warning triangle can be

space between the front seats or in

accommodated in the space under

the overhead console.

the front seats.

Underseat storage 3 68.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Storage

An additional fire extinguisher may be

Roof rack system

Loading information

located in the front door panel or in the

load compartment.

Roof rack

●

Heavy objects in the load

compartment should be evenly

For safety reasons and to avoid

distributed and placed as far

damage to the roof, the vehicle

forward as possible. If objects

approved roof rack system is

can be stacked, the heavier

recommended.

objects should be placed at the

Follow the installation instructions

bottom.

and remove the roof rack when not in

●

Secure objects with lashing

use.

straps attached to lashing eyes

3 69.

●

Secure loose objects in load

compartment to prevent them

from sliding.

●

The load must not obstruct the

operation of the pedals, parking

brake and gear selector lever, or

hinder the freedom of movement

of the driver. Do not place any

unsecured objects in the interior.

●

Do not drive with an open load

compartment. In addition, the

number plate is only

distinguishable and illuminated

correctly if the doors are closed.

Content .. 2 3 4 5 ..