Iran Khodro Samand SE. Service Manual - part 2

22

2

LOCKING AND UNLOCKING OF DOORS

Key set

Your car is supplied with a key set, which 

consists of:

1- Two radio remote controls switches.

3- Two disconnecting alarm switches*

4-Key identification tag

There is a carved number in the identification 

tag which is needed in the case of replacing 

the key. Therefore it should be kept in a safe 

place and never leave it in the car.

Remote keyless entry system*

Hold the remote control system in the 

direction of the vehicle and then press the 

buttons.

(Unlock) Press button”1” to unlock the 

doors (Theft-deterrent system is turned off) 

(Lock) Press button “2” twice to lock the 

trunk (Theft-deterrent system is turned on) 

Jack knife keys*  

Pressing the switch 4 (folding switch lock 

or Jack Knife) cause the switch blade to 

be opened in clockwise direction.

Place the blade in its location by holding 

the switch lock and turning the switch 

blade in counterclockwise.

Notice

Continuous pressing of the switches 

within a short period causes their 

function to be stopped for 20 second.

Note

There is possibility of breakage for 

internal parts of the remote controller in 

case of sever impact and subsequently 

not functioning of the immobilizer.

23

2

LOCKING AND UNLOCKING OF DOORS

* If equipped

Remote keyless entry system*

Hold the remote control system in the 

direction of the vehicle and then press the 

buttons.

1- (Unlock) Press button”1” to unlock the 

doors(Theft-Deterrent system is turned off) 

2- (Lock) Press button “2” twice to lock the 

trunk (Theft-Deterrent system is turned on)

3- Press botton 3 twice to unlock the boot 

door.(two frequently pressing)*

When button 1 is pressed once, just the 

door near driver is opened and with pressing 

again rest of the doors is opened.*

Automatic locking of doors*

If the doors are unlocked by remote controller 

but none of the doors are opened within a 

certain time

1

, doors will be locked again. This 

function is for avoiding unintended unlocking 

of the doors by unwanted pressing of the 

unlocking switches on the remote controller. 

Doors are locked automatically during 

driving, when the speed of the vehicle goes 

more than 10 km per hour.

2

It’s possible to activate or deactivate this 

capability by pressing the central lock key

for 5 seconds and then releasing it.

At the time of activation, central key light 

flashes  3  times  and  audio  warning  is 

heard.

 

Automatic unlocking of doors *

If the doors are locked, when ignition 

switch is in the “OFF” position and start 

switch returns to its initial position, the 

doors will be unlocked. 

2

1-this time is adjustable by diagnostic device of 
the Iran Khodro authorized dealers.
2-This feature may be deactivated by tester
equipment available in IKCO authorized
dealer also.

Notice

Continuous pressing of the switches 

within a short period causes their 

function to be stopped for 20 second.

Note

There is possibility of breakage for 

internal parts of the remote controller in 

case of sever impact and subsequently 

not functioning of the immobilizer.

Locking and unlocking the boot 

by remote controller*

Hold the remote controller toward the 

vehicle. When the vehicle is opened by 

the switch no. 1, press the switch no. 3 

twice, then the trunk lid will be opened.

24

2

LOCKING AND UNLOCKING OF DOORS

Locking/unlocking with the Key

Insert the key into the slot near the driver 

and turn left to unlock and right to lock.

All doors, trunk lid and fuel filler cap will 

be locked.

Lock/unlocking of the trunk lid* 

When the central (door) locking system is 

locked using either the key or the remote 

control, access to luggage area would be 

possible by using the key for the trunk lid 

lock. Insert the key into the trunk lid slot 

and turn left to unlock,and then press lock 

button to open it. To lock again, turn the 

key to right and remove it.

Child safety locks

Positioned under the each rear door lock. 

The child locks prevent the opening of rear 

doors from the inside and act independent 

of the central (door) locking system. 

To latch the children just push the lever 

down to operate.

Tip

If your vehicle is locked using the 

remote control switch and you start 

to open the vehicle doors or its rear 

trunk by manual key, the burglar alarm 

system will become activated and the 

alarm will sound.

* If equipped

25

2

* If equipped

LOCKING AND UNLOCKING OF DOORS

Trunk lid lock release*

Hold the remote control towards the radio 

transmitter and press the button twice 

with the trunk lid symbol (button”3”) on the 

remote keyless entry transmitter in less 

than a second to open the trunk When the 

central door locking system is activated 

with the remote transmitter or automatic 

warning locking system, Access to 

luggage compartment is possible; But we 

should close the boot with in 20 seconds, 

otherwise the antitheft system and alarming 

will be activated. Therefore the car should 

be unlocked by holding the remote control 

button at first( Pressing button “1”). To lock: 

Only by locking trunk, the access to the 

trunk would be impossible completely.

Releasing trunk lid lever and cable*

Pull down the armrest located in the 

middle of the rear seat, and release trunk 

lid latch. and pull down the latch till it will 

be placed on the armrest. Take your hand 

beneath left side of rear shelf. There is 

a lever and a cable installed –it can be 

accessed from the interior of the trunk - 

which will open the trunk in emergency 

occasions such as lack of internal 

electricity power, malfunction of trunk lock 

releasing button on the remote keyless 

entry system and dashboard. In the above 

mentioned situations slid the lever to the 

right. Therefore the trunk will be unlocked 

mechanically.

To lock well the trunk lid, please put the 

mechanisms lever in the place.

26

2

BATTERY REPLACEMENT

Battery replacement of the remote control 

switch (Remote keyless entry system switch)

1- Separate the part 1 and 2 with the help of 
hand pressing  from the described line. 
2- Then separate the upper  and  Lower part of 
the section 2 by hand pressing  (fig B). 
3- Remove the discharged battery and replace the 
new one. Ensure the battery has been inserted 
properly(fig C). Use the battery of CR 2032.
4- Put the upper and lower part on each other 
and insert it by hand pressing. 
5- Put part 1 and 2 on each other and insert it 
by hand pressing.

Warning

Never discard used batteries in 

Nature. Give them to organizations 

responsible for collecting and recycling 

this kind of batteries.

Warning

Avoid keeping the battery or remote 

controller in infants’ access, because 

swallowing of the battery can cause 

death. In case of swallowing the battery, 

refer to health care centers immediately.

* If equipped

Battery Replacement of the Remote 

Control Switch*

If the indicator light on switch is not blinked 
or the key is not functioned correctly, it is 
necessary the battery be replaced. For 
replacement  of  the  battery,  first  open  the 
buckle and separate the switch back frame 
with proper pressure to gap between up/down 
frame. Confirmed battery is CR2032. 

Remember;

 even, when the remote control 

batteries have been discharged, central key 
system operates by the key. If it's possible, 
don't utilize used batteries.

27

2

IMMOBILIZER 

Anti-Theft security system (Immobilizer)

The vehicle with immobilizer system, 

can only start up with two keys which is 

delivered to customer with the vehicle. 

Notice: 

Copy ing key is not enough for start up. It is 

possible to have more keys if the customer 

requests and only in IRAN KHODRO dealers 

with the DIAG tool. To maintain better and 

usage of your vehicle, it is necessary to pay 

attention to the following tips: 

1. Keys have electronic chip inside which 

contains information of key codes, so 

avoid putting them near powerful electro 

magnetic and electrical scopes. 

2.When delivery the vehicle, there is a card 

which is shown in left picture with the keys. 

Existence of this card is necessary in cases 

like multiplying the key (from 2 up 5 at max) 

or replacement of lost key, replacement of 

electronic unit of Anti-theft security system 

(immobilizer) or replacement of ECU with 

ownership document of vehicle. Above 

functions are impossible if the card is 

lost and leads to replace whole security 

system. All costs due to careless keeping 

must be paid by owner.

Note 

There is possibility of breakage for 

internal parts of the remote controller in 

case of sever impact and subsequently 

not functioning of the immobilizer.

Attention

This system will check the engine’s 

electronic system, a little after the 

engine is turned off and thus prevent 

anyone without the main key from 

turning on the engine. 

Caution

- The anti-burglary system your vehicle 

is equipped with, is one of the soundest 

security systems, increasing the 

vehicle’s security ratio, without need of 

doing any special functions. Naturally 

this should not make the vehicle 

owner careless regarding proper and 

adequate protection of his car. 

- Any repairs or changes in the anti-

burglary system (electronic box, wiring, 

etc.) are strictly forbidden. 

28

2

* If equipped

Warning

Consider that front passengers 

should not have their seatbacks 

reclined if their vehicles are moving. 

The complete seat belts performance 

is gained when backrest angle is 

about 25 from vertical axis.

Warning 

Do not adjust the seat while driving 

the car.

Moving seat forward / backward

1- Pull up the lever

2- Slide the seat to the favored position 

(by pressing your weight) 

3- Release the lever till it will be locked. 

Before driving be sure of adjusting the 

seat as needed.

Adjusting seatback

To adjust the seatback angle of the seat, 

turn the adjusting knob.

(Adjusting the seatbelt is done by a lever 

in certain models). *

Adjusting lumbar support*

Rotate the hand wheel to increase or decrease 

support to the lumbar region of the back.

Backrest power adjustment*

After starting the car with the ignition 

switch, press the adjustment electrical key 

beside the seat to adjust the backrest.

SEATS

29

2

Adjusting seat height (Driver’s 

seat only)*

To adjust, sit on the seat and pull out 

the telescopic lever. Pull up the lever to 

increase the seat height, and respectively 

pull down to lower it.

SEATS

Warning

- When pulling down the seat make 

sure that rear passenger’s feet are 

not beneath the seat.

- Do not adjust the seat while driving 

the car.

- As headrest is a safety accessory, 

make sure it is installed in the 

correct position.

- To open the seat please refer to  

the authorized dealer of IKCO.

- Take care of the seat adjusting 

rods so as not to be hindered by 

the cover strings and ties; If you use 

any fabric slip or cover.

* If equipped

Adjusting seat height (Driver’s 

seat only)*

To adjust, sit on the seat and pull up the 

lever,decrease your pressure on the 

seat so that you can reach to a desirable 

height; then release the lever.

To decrease the seat height; press the 

lever downwards and decrease the height 

by your weight and pressure on the seat 

so that  you can reach to a desirable 

height.

30

2

SEATS

Adjusting headrest height 

To adjust the headrest, lift it up to make it 

level with your nape. To lower it, pull the 

seat lever down.

Notice:

Considering an extreme force for pulling 

out the headrest, which in itself may 

damage the seat, avoid pulling it out 

except at emergency instances.

Head position on the headrest

Headrest is designed to restrain rear 

movement of the head at event of an 

accident or a sudden stop. 

If properly adjusted, a headrest can help 

reduce the risk of trauma to the neck and 

head during an accident.

In the meanwhile, the head rest is rotatable 

backward and forward in its own position.

(according to above figure)*

Warning

To avoid the decrease in efficiency of 

the safety belt, it should be positioned 

on your shoulder and make sure the 

seat back is adjusted in an appropriate 

and correct position.

Caution

To limit the risks of injury to the 

driver and to secure him and front 

passenger, it is necessary to adjust 

head restraint height and position 

of your head toward it as per above 

illustration.

* If equipped

31

2

SAFETY BELTS 

Seat belts safety tips

Seat belts are designed for people of adult size, and they must be used by only one person at a time. Always make sure that all 

passengers’ belts are fastened (properly), and consider the following precautions: 

- Do not let passengers recline the seats extremely rearwards. The complete performance is gained when backrest angle is about 25 ° 

from vertical axis.

- Adjust safety belts to eliminate any slacks. Do not pull the belt away from the body while running. To operate properly, safety belts 

should be worn as tightly as possible.

- The lap part of the belt should not go over the abdomen but pelvic bones. The shoulder belt should go over the shoulder and across 

the chest without any pressure to the neck.

- Remove hard, sharp or fragile objects as keys, pens, glasses and etc. from your clothes. The belt should not be  twisted, and there 

would be no obstacle in between.

-Replace seat belts if they are worn, lost their sensitivity or damaged

- Use the seat belts to fix luggage carried on the seats. Throwing loose packages in passengers’ compartmen during an accident can 

cause serious injuries.

- In most countries, all passengers are legally obligated to wear safety belts unless be exempted on medical certificate.

- Pregnant women should pass the shoulder portion across the shoulder, breast cleavage and from one side of the fetus. If in doubt, 

consult your physician.

32

2

SAFETY BELTS 

Wearing safety belts

Pull the belt across you slowly. Do not let 

it get twisted. Insert the latch plate into the 

buckle until it clicks. A “click” ensures us 

that the two sections of the safety belts 

have joined together. Your vehicle has 

a safety belt reminder light to remind us 

about fastening the driver’s belt. After 

buckling up the drivers’ belt, the warning 

light on the digital dashboard will turn off.

Releasing the safety belt 

Press the red button on the belt lock. The 

belts are designed to cover the body skeleton 

(pelvis, chest and shoulders) and are only 

useful and safe when the seats are almost 

vertical. Do not allow the front passengers to 

travel with the seat steeply reclined.

Adjusting height of front seat belts

To adjust belt height, pull out the heigh 

adjusting knob and fix it in some lower or 

upper level.

For safety reasons it is advisable that children 

should use the back seats of the vehicle.

Warning

- All seatbacks should always be in an upright position while driving, or seat belt 

effectiveness may be reduced. Never let the front passengers recline the front seats. 

Otherwise the safety belt reminder light on digital display panel turns off.

- Do not let external objects (especially sticky substances) penetrate the buckle 

causing its improper operation.

33

2

TRACTION SYSTEM A & PRESSURE LIMITER 

Pre- Tensioner & Pressure Control

In case of a front collision, safety of the front 

seats will improve due to the safety belts 

equipped with interjecting and pressure 

restricting systems, and depending on the 

blow’s severity, the pre-loading traction 

system will tighten the bets and pull it 

even more towards the driver and front 

passenger seat. 

1- The pre-loading traction system will become 

activated when the car key is turned on. 

2- Belt’s pressure limiters: this mechanism 

will reduce pressure on passenger’s chest 

at time of collision.

Pre- Tensioner belt

The safety belt is activated together with 

the airbag only at time of receiving strong 

blows resulting from front collisions. They 

are not designed for blows from the rear, 

sides (sideswipes), vehicle overturning 

or minor collisions at front and for this 

reason they do not become activated. The 

Interjecting part of the belt may be activated 

only once. If this system is activated once 

(i.e. when the air bag becomes active), 

the Interjecting part of the bet should be 

serviced by an authorized Iran Khodro 

representative as soon as possible.

Warning

-Servicing and checking the belt’s 

interjecting system and ites wiring 

should be performed by specially 

trained persons at Iran khodro 

authorized representatives. Any 

tempering and improper repair of the 

system may result in unwanted or faulty 

activatiion or its failure. Any of these 

may result in personal injuries.

- Only belts fastened as tight as 

possible on the passenger’s body 

will have the needed effectiveness. 

Depending on the blow’s nature and 

severity, the interjecting system will work 

concurrently with the air bags.

In case of non-performance in one of 

thhe above cases or system defect, the 

bag’s warning light will come on.  

34

2

CHILD SAFETY 

Notice: People under the age of 7or 

8 considered children because of the 

different ratio of head to body weights. 

In violent deceleration, the weight of the 

head and relatively weakness of neck 

muscle can make serious spinal injuries. 

They can be considered as young children 

till reached 13 years of age or at a height 

of more than 137 centimeters. 

This is why most countries have envisaged 

some rules for the purpose of using and 

selling suitable child restraints.

Babies under the 9 months (and less than 

10 kg) must be secured on a rear-facing 

seat in front of the car. Actually infant 

restraints provide restraint with the seating 

surface against the back of the car with 

a three-point belt-seat belt with locking 

mechanisms (or inertia reel belt).

The seat of the child from 9 months to 

3 years (up to 18 Kg) should be placed 

forward-facing in the rear of the car and 

fixed with a three-point belt (lap-and-sash 

or inertia reel belt).

Warning

Nothing should be placed under the 

driver’s feet; otherwise it may slide 

under the pedals by a sharp braking 

and lead to malfunction of the brake 

in an emergency situation.

Warning

- In order to maintain the safety, children under 13 years should sit on the seat backward.
- Children under 13 years should never sit on the seat front .
Make sure of air bag deactivation while the infant seat back is located towards the road in 
front passenger seat ;otherwise there is every possibility of sever injury or even death of the 
infant due to air bag being opened. locate the seat in the middle position, longitudinally , adjust 
the back vertically and activate the air bag while the infant seat is towards the road in front 
passenger seat.  

35

2

CHILD SAFETY 

For children (weighing more than 15 kg) 

equal or greater than 3 years old (more than 

15 Kg), a booster seat can be used in the 

rear of the car, facing forward, using a 2 or 3 

point (lap or inertia reel) seat belt (especially 

suitable for children roughly 3 to 6 years old).

For heavy children –whose weight exceeds 

the limits of standard seat- who are equal or 

greater than 3 years old should be seated, 

a forward- facing booster cushion, in the 

rear of the car, using a 2 or 3 point (lap or 

inertia reel) seat belt.

(Especially suitable for children roughly 3 

to 6 years old).

Warning

-The children shall not be seated on 

the lap of the passengers; otherwise 

they may be hurt by an accident.

- Never fasten a seat belt at a time for 

two persons.

36

2

* If equipped

EXTINGUISHER 

Extinguisher* 

It is necessary that owners learn about 

usage of car extinguisher.

Product Specification: 

1. This kind of capsule contains dry 

chemical powder with 16 gr high pressure 

CO2 cartridge (capsule). During operation, 

after release cotter pin, gas inside cartridge 

will mixed with dry powder and mixture is 

ready to void. 

2. Maintenance and operational accordance 

within -30 to 90° C temperature. 

3. This kind of capsule doesn’t need to be 

checked for 5 years and if it is used, it will 

be easy to recharge again. 

4. Non conglomeration of powder in the case 

of any car vibration, high temperature and car 

accident is one of the pros of this capsule. 

How to use

Activation procedure of capsule is written 

in English language on it’s body as follow 

which must be read carefully. 

- Pull out cotter pin 

- Pull out cap cotter pin upward 

- Aim the nozzle toward fire center and press 

handle downward for powder discharge 

Notice

To prevent of fire expanding due to air feeding in engine compartment, do not open the hood completely. After release cotter pin 

and activation the capsule, open the hood about 10 to 15 cm with discretion and care then simultaneously discharge the mixture in 

fire center about 1 to 2 seconds. After that open the hood and completely discharge the capsule in fire center. Pay attention that the 

capsule weight is 1 kg and it’s discharge duration is about 7-10 seconds. there fore paying attention during operation is so necessary.

37

2

EXTINGUISHER 

Important tips 

1.Never  open  discharge  valve  of  fire 

extinguisher. This cause to lose quality 

of  material  inside  fire  extinguisher  and 

reduces it’s power. 

2.If the door and windows are locked and 

impossible to open due to fire emergency 

or  emergency  conditions,  take  the  fire 

extinguisher which is placed under front 

passenger seat and break the window by 

its end then exit the car. 

3.Although  the  material  inside  fire 

extinguisher is not poisoning, never 

discharge it toward face and eyes. 

4.During installation inside the car, pay 

attention that fire extinguisher is well placed 

and it’s plastic mounting belt is properly 

locked, otherwise in case of impact or 

accident it moves from it’s place.

5.During fire emergency, always be cool 

and follow the procedure carefully. 

6.The  1  kg  fire  extinguisher  is  just 

designed for control and restrains the fire 

at beginning so in case of fire emergency 

which expands in large area, notify the fire 

department  to  help  and  control  the  fire. 

The  mentioned  fire  extinguisher  has  no 

efficiency in above case.

Caution

Experience and coolness are two 

fundamental skills during usage of fire 

extinguisher, so car manufacturer has 

no commitment to owner due to non 

correct usage of fire extinguisher.