|
|
|
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control
modules and control module pins.
DATE OF ISSUE:
July 1999
Fig. 16.7
COMPONENTS
Component
Connector(s)
Connector Description
Location
NAVIGATION CONTROL MODULE
CA107
10-WAY / WHITE
TRUNK, LH SIDE
CA108
18-WAY / WHITE
TRUNK, LH SIDE
NAVIGATION DISPLAY MODULE
FC67
20-WAY / WHITE
FASCIA, CENTER
TELEVISION AMPLIFIER – FRONT
BF7
1-WAY / BLACK
FRONT BUMPER
BF8
1-WAY / BLACK
FRONT BUMPER
BF9
1-WAY / BLACK
FRONT BUMPER
FH100
1-WAY / BLACK
FRONT BUMPER
FH101
1-WAY / BLACK
FRONT BUMPER
TELEVISION AMPLIFIER – REAR
BR8
10-WAY / GREY
REAR BUMPER
TELEVISION MODULE
CA163
20-WAY / WHITE
BELOW PARCEL SHELF
TELEVISION MONITOR
FC90
18-WAY / WHITE
NAVIGATION DISPLAY
TRAFFIC MASTER ANTENNA
CA175
10-WAY / BLACK
TRUNK
CA176
10-WAY / BLACK
TRUNK
TRAFFIC MASTER MODULE
CA174
5-WAY / GREEN
TRUNK
VEHICLE EMERGENCY CONTROL MODULE
RA6
12-WAY / BLACK
TRUNK, LH SIDE
RA7
16-WAY / BLACK
TRUNK, LH SIDE
VEHICLE INFORMATION CONTROL MODULE
CA162
10-WAY / BLACK
TRUNK, RH SIDE
VEMS GPS ANTENNA
CA134
10-WAY / GREY
PARCEL SHELF
HARNESS IN-LINE CONNECTORS AND JUNCTION CONNECTORS
Connector
Connector Description
Location
FC57
16-WAY / BLUE / CABIN HARNESS TO FASCIA HARNESS
BEHIND DRIVER SIDE DASH LINER
FC82
12-WAY / BLACK / CABIN HARNESS TO FASCIA HARNESS
BEHIND FASCIA END PANEL, LH SIDE
FH98
10-WAY / BLACK / CABIN HARNESS TO FRONT HARNESS
ENGINE COMPARTMENT
RA3
10-WAY / GREY / CABIN HARNESS TO VOICE LINK LEAD
TRUNK; ABOVE WHEEL ARCH, LH SIDE
GROUNDS
Ground
Ground Description
Location
CA157
GROUND EYELET
BEHIND REAR SEAT BACK; RH SIDE / SEAT BACK
FC38
GROUND EYELET
BEHIND CENTER CONTROL CONSOLE / CENTER CONSOLE TRIM
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control
modules and control module pins.
DATE OF ISSUE:
July 1999
Fig. 17.1
COMPONENTS
Component
Connector(s)
Connector Description
Location
AIRBAG – DRIVER
DB4
2-WAY / YELLOW
BEHIND SEAT BACK FINISHER
CS6
10-WAY / BLACK
ON THE REAR OF THE DRIVER AIRBAG ASSEMBLY
AIRBAG – PASSENGER
FC32
2-WAY / BLACK
LH SIDE OF AIRBAG ASSEMBLY
PB4
2-WAY / YELLOW
LH SIDE OF SEAT SQUAB
RESTRAINTS CONTROL MODULE
CA1
8-WAY / BLACK
TRANSMISSION TUNNEL
CA114
26-WAY / BLACK
TRANSMISSION TUNNEL
SEAT BELT PRETENSIONER – DRIVER
CA23
3-WAY / BLACK
LOWER ‘B/C’ POST
SEAT BELT PRETENSIONER – PASSENGER
CA59
3-WAY / BLACK
LOWER ‘B/C’ POST
SECONDARY JUNCTION BOX
CA26
16-WAY / BLUE
FRONT BULKHEAD, FORWARD OF ‘A’ POST, LH SIDE
CA27
8-WAY / GREY
FRONT BULKHEAD, FORWARD OF ‘A’ POST, LH SIDE
FC10
16-WAY / GREEN
FRONT BULKHEAD, FORWARD OF ‘A’ POST, LH SIDE
FH10
10-WAY / YELLOW
FRONT BULKHEAD, FORWARD OF ‘A’ POST, LH SIDE
SIDE IMPACT SENSOR – DRIVER
CA22
2-WAY / BLACK
BELOW SEAT
SIDE IMPACT SENSOR – PASSENGER
CA58
2-WAY / BLACK
BELOW SEAT
HARNESS IN-LINE CONNECTORS AND JUNCTION CONNECTORS
Connector
Connector Description
Location
CS1
3-WAY / BLACK / FASCIA HARNESS TO COLUMN SWITCHGEAR HARNESS
BELOW STEERING COLUMN
DB2
3-WAY / BLACK / DRIVER SEAT HARNESS TO SEAT BACK LINK LEAD
BEHIND SEAT BACK FINISHER
DM19
2-WAY / YELLOW / CABIN HARNESS TO DRIVER SEAT HARNESS
BELOW SEAT CUSHION
FC6
3-WAY / BLACK / CABIN HARNESS TO FASCIA HARNESS
BEHIND FASCIA END PANEL, LH SIDE (LHD) OR RH SIDE (RHD)
FC7
3-WAY / GREY / CABIN HARNESS TO FASCIA HARNESS
BEHIND FASCIA END PANEL, LH SIDE
FC9
3-WAY / BLACK / CABIN HARNESS TO FASCIA HARNESS
BEHIND FASCIA END PANEL, RH SIDE (LHD) OR LH SIDE (RHD)
FC58
20-WAY / BLACK / CABIN HARNESS TO FASCIA HARNESS
BEHIND LOWER ‘A’ POST TRIM, LH SIDE
FH5
16-WAY / GREY / CABIN HARNESS TO FRONT HARNESS
BEHIND LOWER ‘A’ POST TRIM, LH SIDE
PB2
3-WAY / BLACK / PASSENGER SEAT HARNESS TO SEAT BACK LINK LEAD
BEHIND SEAT BACK FINISHER
PN5
2-WAY / YELLOW / CABIN HARNESS TO PASSENGER SEAT HARNESS
BELOW SEAT CUSHION
GROUNDS
Ground
Ground Description
Location
CA30
GROUND EYELET
LOWER ‘A’ POST; LH SIDE / ‘A’ POST TRIM
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control
modules and control module pins.
DATE OF ISSUE:
July 1999
Fig. 18.1
COMPONENTS
Component
Connector(s)
Connector Description
Location
PARKING AID CONTROL MODULE
CA112
26-WAY / BLACK
IN THE SPARE WHEEL WELL
PARKING AID SENSOR – CENTER LH
BR3
3-WAY / BLACK
REAR BUMPER
PARKING AID SENSOR – CENTER RH
BR4
3-WAY / BLACK
REAR BUMPER
PARKING AID SENSOR – LH
BR2
3-WAY / BLACK
REAR BUMPER
PARKING AID SENSOR – RH
BR5
3-WAY / BLACK
REAR BUMPER
PARKING AID SOUNDER
CA32
1-WAY / GREY
PARCEL SHELF
ROOF CONSOLE SWITCH PACK
RF26
8-WAY / WHITE
ROOF CONSOLE
HARNESS IN-LINE CONNECTORS AND JUNCTION CONNECTORS
Connector
Connector Description
Location
BR1
10-WAY / GREY / CABIN HARNESS TO BUMPER HARNESS
BEHIND RH REAR QUARTER TRIM
RF34
14-WAY / GREY / CABIN HARNESS TO ROOF HARNESS
BELOW PARCEL SHELF
GROUNDS
Ground
Ground Description
Location
CA116
GROUND EYELET
BEHIND REAR SEAT BACK; RH SIDE / SEAT BACK
The following abbreviations are used to represent values for Control Module Pin-Out data
I
Input
S
SCP Network
B+
Battery Voltage
Hz
Frequency
O
Output
A
ACP Network
V
Voltage (DC)
kHz
Frequency x 1000
REF
Reference Voltage / Ground
D
Serial and Encoded Data
PWM
Pulse Width Modulated
mA
Milliamperes
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation.
THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all components
connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, control
modules and control module pins.
DATE OF ISSUE:
July 1999
Fig. 19.1
COMPONENTS
Component
Connector(s)
Connector Description
Location
ACCESSORY CONNECTOR
CA13
10-WAY / BLACK
ADJACENT TO FUEL FLAP SOLENOID
CIGAR LIGHTER
CA109
3-WAY / BROWN
CENTER CONSOLE
FRONT POWER DISTRIBUTION BOX
ENGINE COMPARTMENT, RH FRONT
GENERAL ELECTRONIC CONTROL MODULE
CA24
26-WAY / WHITE
‘A’ POST, LH SIDE
CA31
20-WAY / BLACK
‘A’ POST, LH SIDE
CA84
4-WAY / GREY
‘A’ POST, LH SIDE
FH9
22-WAY / BLACK
‘A’ POST, LH SIDE
FH59
12-WAY / BLACK
‘A’ POST, LH SIDE
FH60
17-WAY / BLACK
‘A’ POST, LH SIDE
HORNS
FH29
2-WAY / BLACK
FORWARD OF RADIATOR
INSTRUMENT PACK
FC14
22-WAY / GREY
FASCIA
FC15
20-WAY / BLACK
FASCIA
FC63
22-WAY / BLACK
FASCIA
PRIMARY JUNCTION BOX
CA2
26-WAY / BLACK
‘A’ POST, RH SIDE
CA56
8-WAY / GREY
‘A’ POST, RH SIDE
FC37
26-WAY / BLACK
‘A’ POST, RH SIDE
FH7
6-WAY / GREY
‘A’ POST, RH SIDE
FH53
10-WAY / GREY
‘A’ POST, RH SIDE
ROOF CONSOLE SWITCH PACK
RF26
8-WAY / WHITE
ROOF CONSOLE
STEERING WHEEL
CS5
10-WAY / BLACK
STEERING WHEEL
SUNSHADE MOTOR ASSEMBLY
RF25
10-WAY / GREY
BELOW PARCEL SHELF
HARNESS IN-LINE CONNECTORS AND JUNCTION CONNECTORS
Connector
Connector Description
Location
CS2
10-WAY / BLACK / FASCIA HARNESS TO COLUMN SWITCHGEAR HARNESS
BELOW STEERING COLUMN
RF34
14-WAY / GREY / CABIN HARNESS TO ROOF HARNESS
BELOW PARCEL SHELF
SL3
10-WAY / GREY / FASCIA HARNESS TO ROAD PRICING MODULE LINK LEAD
BEHIND FASCIA END PANEL, RH SIDE
GROUNDS
Ground
Ground Description
Location
CA116
GROUND EYELET
BEHIND REAR SEAT BACK; RH SIDE / SEAT BACK
CA141
GROUND EYELET
BELOW FRONT SEAT; LH SIDE / UNDER SEAT
CA156
GROUND EYELET
TRUNK; RH REAR SIDE; ADJACENT TO RECM / TRUNK RH TRIM
CA50
GROUND EYELET
LOWER ‘A’ POST; RH SIDE / ‘A’ POST TRIM
FC38
GROUND EYELET
BEHIND CENTER CONTROL CONSOLE / CENTER CONSOLE TRIM
FH42
GROUND EYELET
ADJACENT TO ABS/TC OR DSC CONTROL MODULE / ENGINE COMPARTMENT
CONTROL MODULE PIN-OUT INFORMATION (FOLD OUT PAGE)
CONTROL MODULE PIN-OUT INFORMATION
General Electronic Control Module
P
Pin
Description
Active
Inactive
S
FH59-1
SCP -
2 – 1600 Hz
S
FH59-7
SCP +
2 – 1600 Hz
O
FH59-8
HORN RELAY ACTIVATE
GROUND
B+
Instrument Pack
P
Pin
Description
Active
Inactive
I
FC15-10
HORN SWITCH
GROUND (MOMENTARY)
B+
S
FC15-15
SCP +
2 – 1600 Hz
S
FC15-16
SCP -
2 – 1600 Hz
NOTE: Refer to the Appendix at the rear of this book for SCP Network Messages.
|
|
|