JAC Trucks. Manual - part 108

 

  Index      JAC     JAC Trucks - service repair manual

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  106  107  108  109   ..

 

 

JAC Trucks. Manual - part 108

 

 

67

Trouble symptom and probable cause

Checking and remedy

(1)Not start

(a)Incorrect connection
(b)Barry output Incorrect connection
(c)Lubricant is not the standard.
(d)Start the relay is incorrect.

(d) Clean the battery
(b) Clean and tight it
(c) replace lubricant
(d) repair and replace

(2)Insufficient electric capacity

(a) New battery without circulation of charge and dis鄄

charge, or not been charged to rated quantity.

(b) Generator without charge or enough charge.
(c) Damaged pole plate.
(d) Low level or improper specific gravity of electrolyte

(a)Charge as specified

(b)Check connections and repair
(c) Check and repair
(d)Fill up electrolyte and charge battery with it separated
from vehicle

1援Electrical parts trouble shooting

66

Being used, the vehicle will often be
broke along with it travels longer and
longer. In order to recover vehicle to
normal proper situation, also to pro鄄
long its life, the trouble must been
find out and then been disposed in
an effective way.
* To shoot troubles of engine, see
Engine Operating Instruction Manual
which every vehicle have been e鄄
quipped.

Checking and remedy of electri鄄
cal system
fuel gauge not move

Spread fuel-gauge and take it iron, if
the fuel -gauge needle point toward
fuel-gauge have already break down
or the instrument fuse was burn out,
should check to fix or replace. If the

fuel-gauge still motionless, it means
the fuel-gauge to break down.
The hydraulic indicator isn't bright:
Dismantle hydraulic -pneumatic alert
machine bottom, and take it iron. If
the hydraulic-pneumatic indicator is
bright at this time, the elucidation is
hydraulic -pneumatic to report the
machine switch damage, should re鄄
place. If still not bright, explain the
index sign lamp bulb burn bad,
should replace, perhaps is launch
the engine oil road contain break鄄
down.
Dynamo is not work
Dynamo is work well, but indicator
light is not work.The main cause of
lamp connection is not well.

HFC1048

series trucks

69

2. Clutch trouble shooting

Trouble symptom and probable cause

Checking and remedy

(1) Shaking clutch

a. Overloading too much vehicle

b. Not start in low gear

c. Defective release bearing or insufficient oil

d. Corrugated fin cracked, friction lining worn, loose rivet,

damper spring broken, or damper fin broken down.

a. Load by rated load

b. Start in first gear when loading much

c. Clean, lubricate or replace

d. Replace

(2) Clutch Slip

a. Thin friction lining, rivet reveal, or oil coat

b. Weak pressure of diaphragm spring

c. Too short free play of pedal

d. Vehicle loads too much

e. Not start in low gear

f. The pedal is hold pressed when running

a. Clean, or rivet a new friction lining

b. Replace

c. Adjust to 3~5mm

d. Load accord the rated load

e. Start in low gear

f. Change your bad driving habit

68

Trouble symptom and probable cause

Checking and remedy

渊3冤Too much waste of electrolyte

(a) High charging amperage. Elactrolyte vaporize or ov-

erflow

(b) Leak battery

渊a冤Reduce the frequency of starting and shorten the start鄄
ing time .Decrease amperage of charging current
渊b冤Replace cover of the battery.

渊4冤Self-discharge of battery

渊a冤Battery output cable short to ground
渊b冤A short circuit between pole plates
渊c冤Damaged or breakdown cell divider

渊d冤Dire external surface of battery case .Metal impurities

mixed into electrolyte

渊a冤Clean the output cable ,dispose the short
渊b冤Check and repair
渊c冤Check and repair
(d) Clean the battery case .Tighten shield .Replace elec鄄
trolyte if necessary

HFC1048

series trucks

70

Trouble symptom and probable cause

Checking and remedy

(3) Clutch can't release completely

a. Too long free play of pedal

b. Wear or crack locking collar

c. Crack or distort of wave sheet

d. Broken damper spring

a. Adjust to 3~5mm

b. Replace

c. Replace

d. Replace

(4) Gears hard to mesh

a. High speed idle speed of engine
b. Improper meshing of clutch
c. Coherence of clutch plate
d. Bend clutch slip sleeve

a. Adjust the idle speed
b. Adjust clutch
c. Repair or replace
d. Replace

HFC1048

series trucks

71

Trouble symptom and probable cause

Checking and remedy

(1) Noise or vibration of driveshaft

a. Worn universal joint

b. Bending of drive shaft
c. Loose couple flange or center bracket bolts
d. Defective center bracket rubber sleeve
e. Insufficient lubrication

a. Change spider direction or replace universal joint as鄄
sembly
b. Align or replace
c. Retighten
d. Replace
e. Fill up after cleaning

(2) Overheating center bracket

a. Too much tight of oil seal

b. Too bigger a inclination between drive shaft and

crankshaft

c. Insufficient lubrication

a. It will disappear along with travel longer
b. Check and adjust the inclination

c. Fill up regularly

3援Drive shaft trouble shooting

72

Trouble symptom and probable cause

Checking and remedy

(1) Gears break off

a. Worn or damaged coupling
b. Loosen nuts or bolts
c. Improperly adjusted linkage
d. Distorted, worn, or crack spring or locking ball
e. Worn shift fork and groove face
f. Worn synchronizer hub and sleeve
g. Worn or damaged synchronizer hub and engagement

sleeve

h. Worn or damaged bearing of input shaft and output

shaft

i. Worn or damaged thrust ring and thrust washer
j. Loosen bolts which mount transmission to engine

a. Replace the coupling
b. Tighten
c. Readjust
d. Repair or replace parts
e. Replace shift fork
f. Replace
g. Replace

h. Replace bearing

i. Replace
j. Tighten

4. Transmission trouble shooting

HFC1048

series trucks

73

Trouble symptom and probable cause

Checking and remedy

(4) Hard to shift

a. Improper adjustment of shift knob
b. Worn hinge joint or pin
c. Worn control mechanism
d. Loosen bolts or nuts

a. Adjust shift knob
b. Replace
c. Replace
d. Check and tighten

(2) Gears hard to mesh

a. High speed idle speed of engine
b. Improper meshing of clutch
c. Coherence of clutch plate
d. Bend clutch slip sleeve

a. Adjust the idle speed
b. Adjust clutch
c. Repair or replace
d. Replace

(3) Noise from transmission

a. Loosen bolts which mount transmission to engine
b. Worn gear or bearing

a. Tighten
b. Replace

 

 

 

 

 

 

 

Content   ..  106  107  108  109   ..