FE11-1811c

6.

Cut the rear window glass adhesive with a thin steel wire.

Note

Wrap both end of the fine steel wire around a wood
handle, operate by with two people to facilitate the
removal.

7.

Removed the adhesive on the rear window glass with a
blade.

8.

Removed the adhesive on the rear window frame with a
blade.

9.

Clean  the  windshield  inner  surface  with  a  cloth  stained
soaked  with  industrial  ethanol  and  water  mixture  with
50/50 volume ratio.

Installation Procedure:

FE11-1806b

1.

Spray the dedicated Geely glass sealant, with 8 mm (0.3
in) width 8 mm (0.3 in) height.

FE11-1807b

2.

With a double-pipe gun evenly apply glass sealant to the
window glass edge to make sure that the sealant width is
even.

3.

With the help of an assistant, install the rear window glass
to the rear window frame.

4.

Press the rear window glass to bond the adhesive to the
seal  strip,  the  rear  window  glass  and  the  rear  window
frame to retain the rear window.

5.

Let adhesive dry 24 h.

6.

Spray water onto the rear window to check for water leaks.
If it leaks, dry the rear window and apply adhesives to the
leaking location. If it still leaks, remove the rear window
and repeat the entire repair procedure.

Body Electric

Glasses / Windows / Mirrors

11-213

7.

Connect  the  rear  window  defroster  wiring  harness
connector.

8.

Install the wiper arms.

9.

Install the hatchback trim panel.

10. Install the high mounted brake lamp.

11. Connect the battery negative cable.

11-214

Glasses / Windows / Mirrors

Body Electric

11.6 Wipers / Washers System

11.6.1 Specifications
11.6.1.1 Fastener Tightening Specifications

Applications

Model

Specifications

Metric (Nm)

US English (lb-ft)

Front Fender Liner Screws

ST4.8

6-8

4.4-6

Washer Fluid Tank Retaining Bolts

M6 × 20

8-11

6-8

Wiper Retaining Bracket

M6 × 20

8-11

6-8

Wiper Motor Bolts

M6 × 20

8-11

6-8

Wiper Arm Connecting Rod Nut

M8

8-9

6-7

Wiper Arm Nut

M8

14-16

10-12

Rear Wiper Motor Bolt

M6 × 20

8-11

6-8

Rear Wiper Arm Nut

M6

8-11

6-8

Body Electric

Wipers / Washers System

11-215

11.6.2 Description and Operation
11.6.2.1 Description and Operation

Wipers  /  washers  system  consists  of  the
following components:

–

Central Controller

–

Wipers / Washers Switch

–

Washer Fluid Tank

–

Washer Pump

–

Wiper Motor

–

Wiper Arm and Connecting Rod Installation

–

IF27 20A Wiper / Washer Switch Fuse

–

Rear Washer Pump (Hatchback)

–

Rear Wiper Motor (Hatchback)

–

Rear Wiper Arm (Hatchback)

–

IF28 10 A Rear Wiper Fuse (Hatchback)

–

Rear Wiper Relay (Hatchback)

Wiper  /  washer  system  can  achieve  high-speed,  low  speed,
intermittent three kinds of wiper speed, and can wiper switch
off automatically after the reset function.

Front Wiper / Washer System

Front wiper system consists of a wiper motor, linkage, wiper
arm, wiper blades as well as the wiper / washer switch. Front
wiper circuit has a self-cut-off device, which consists of a worm
gear and a cam plate. The device aims at temporarily maintain
the circuit integrity when the wiper / washer switch is off until
the  wiper  arm  is  back  to  the  original  position.  Wiper  system
consists of a permanent magnet motor. The front wiper motor
is installed on the front fender and directly connected with the
front wiper rod. The front wiper motor speed has two stages
(high-speed and low speed), and it can operate intermittently.
Wiper  switch  is  a  wiper  /  washer  system  component.  Front
wiper switch is installed on the steering column right side lever.

Windshield Washer System

Windshield  washer  system  consists  of  a  washer  fluid  tank,
washer  pump,  hoses,  nozzles  and  wiper  /  washer  switch.
Windshield washer fluid tank is installed below the right front
headlamp  assembly,  in  the  front  of  the  right  front  fender.
Washer pump is retained on the washer fluid tank, which sends

washing liquid through the hose to the two nozzles installed on
the  engine  hood.  Wiper  switch  is  also  a  washing  /  washer
switch component.

Rear Wiper / Washer System (Hatchback)

Windshield wiper system consists of a rear wiper motor, wiper
arm  and  wiper  blades.  Rear  wiper  motor  is  located  in  the
hatchback,  and  directly  connected  to  the  rear  window  wiper
arms and equipped with a separate washer pump, hoses and
nozzles. Rear washer system shares the same washer tank
and  the  same  washer  pump  with  the  windshield  washer
system. Washer pump sends washing fluid through the hose
to  the  rear  nozzle  installed  on  the  hatchback.  Rear  window
washer nozzle passes through the high mounted brake lamp
cover and retained inside this cover.

11-216

Wipers / Washers System

Body Electric